EVALUATION OF DIFFERENT SOLAR DRYERS AND ITS APPLICATIONS IN JEW'S MALLOW DRYING | ||
| Misr Journal of Agricultural Engineering | ||
| Article 2, Volume 40, Issue 1, January 2023, Pages 21-34 PDF (1.33 M) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2022.155153.1083 | ||
| Authors | ||
| Ramadan A. El-Gamal1; Solaf S. Abd El-Reheem2; Sameh S. Kishk* 1 | ||
| 1Assoc. Prof., Ag. Eng. Dept., Fac. of Ag., Suez Canal U., 41522 Ismailia, Egypt. | ||
| 2Senior researcher at the Ag. Eng. Res. Inst (AEnRI), Giza, Egypt. | ||
| Abstract | ||
| The shortages in conventional fuels along with the continuous rise in their prices have led to an increased emphasis on using solar energy as an alternative source of energy. Thereto, the objective of this study was to evaluate the thermal efficiency of three different types of greenhouse solar dryers and test their performance in Corchorus olitarius drying. Three different greenhouses namely Quonset, Gable-even span and Gothic arch were constructed and tested without load under different air flow rates (0.38, 0.57 and 0.855 kg s-1). The appropriate air flow rate which gives higher thermal efficiency was then applied to investigate the performance of the constructed dryers for drying the fresh Jew's mallow. The results indicated that the thermal efficiency of the dryers increased when the air flow rate decreased. The Quonset dryer reported a higher value of thermal efficiency of 58.48% under the lower air flow rate of 0.38 kg s-1. Consequently, the Quonset dryer showed higher moisture removal of the Jew's mallow during drying. After 16 hours of drying, the moisture content of Jew's mallow decreased from initial moisture of 13.29 (kg water/kg dry matter) to less than 0.5 (kg water/kg dry matter). Meanwhile, the moisture content of the Jew's mallow samples in ambient air was still higher than 1.2 (kg water/kg dry matter) after the same drying time. These results emphasize the importance of using solar dryers, especially the Quonset greenhouse dryer, for the fast and safe drying process of agricultural products. | ||
| Keywords | ||
| Solar dryer; Greenhouse dryer; Thermal efficiency; Jew's mallow; Drying rate | ||
| References | ||
|
Abdellatif, S. M.; Yousef, A. T. M. and Mosad, G. A. (2010): Utilisation of solar tunnel greenhouse as a solar drier for drying seedles grapes. J. of Soil Sciences and Agricultural Engineering, Mansoura University, 1 (4), 363-377.
Abu-Habaga, M. E.; El-Kholy, M. M. and Emara, R. Z. (2010): Utilization of solar energy for drying sugar beet tops. J. of Soil Sciences and Agricultural Engineering, Mansoura Univ, 1 (7) 681-697.
Basunia, M. A. and Abe, T. (2001): Thin-layer solar drying characteristics of rough rice under natural convection. J. of food engineering, 47 (4) 295-301.
El-Beltagy, A.; Gamea, G. R. and Essa, A. A. (2007): Solar drying characteristics of strawberry. Journal of food engineering, 78(2) 456-464.
ElGamal, R.; Kishk, S.; Al-Rejaie, S. and ElMasry, G. (2021): Incorporation of a solar tracking system for enhancing the performance of solar air heaters in drying apple slices. Renewable Energy, 167, 676 - 684.
ElGamal, R.; Ronsse, F. and Pieters, J. (2013): Modeling deep-bed grain drying using COMSOL Multiphysics. In COMSOL Conference 2013.
El-Sebaii, A. A.; Aboul-Enein, S.; Ramadan, M. R. I. and El-Gohary, H. G. (2002): Experimental investigation of an indirect type natural convection solar dryer. Energy conversion and management, 43(16), 2251-2266.
Famurewa, J. A. V. and Akinmuyisitan, F. A. (2014): Prediction of drying model and determination of effects of drying temperature on Mucilage and Vitamin-C contents of Fluted Jute (Corchorus capsularis) Leaves. Afr J Food Sci Res, 2(11), 149-154.
Furumoto, T. R.; Wang, K.; Okazaki, A. F. M. F.; Hasan, M. I.; Ali, A. K. and Fukui, H. (2002): Antitumor promoters in leaves of jute (Corchorus capsularis and Corchorus olitorius). Food Sci. Technol. Res., 8: 239–243.
Jain, D. and Tiwari, G. N. (2004): Effect of greenhouse on crop drying under natural and forced convection I: Evaluation of convective mass transfer coefficient. Energy conversion and Management, 45 (5), 765-783.
Kishk, S. S.; ElGamal, R. A. and ElMasry, G. M. (2019): Effectiveness of recyclable aluminum cans in fabricating an efficient solar collector for drying agricultural products. Renewable Energy, 133, 307-316.
Kishk, S. S.; El-Reheem, A. S. and ElGamal, R. A. (2018): Experimental and mathematical modeling study for solar drying of mint. Misr Journal of Agricultural Engineering, 35(4), 1327-1344.
Koyuncu, T. (2006): An investigation on the performance improvement of greenhouse-type agricultural dryers. Renewable energy, 31 (7), 1055-1071.
Kumar, A., Singh, R. and Prakash, O. (2014): Review on global solar drying status. Agricultural Engineering International: CIGR Journal, 16 (4), 161-177.
Oboh, G.; Ademiluyi, A.; Akinyemi, A.; Henle, T.; Saliu J. and Schwarzenbolz, U. (2012): Inhibitory effect of polyphenol-rich extracts of jute leaf (Corchorus olitorius) on key enzyme linked to type 2 diabetes (α-amylase and α-glucosidase) and hypertension (angiotensin I converting) in vitro. J. Functional Foods, 4: 450–458.
Phuwapraisirisan, P.; Puksasook, T.; Kokpol, U. and Suwanborirux, K. (2009): Corchorusides A and B, new flavonol glycosides as α-glucosidase inhibitors from the leaves of Corchorus olitorius. Tetra. Letters 50: 5864–5867.
Rabha, D. K.; Muthukumar, P. and Somayaji, C. (2017): Energy and exergy analyses of the solar drying processes of ghost chilli pepper and ginger. Renewable Energy, 105, 764-773.
Radwan, S.M. (2002): Utilization of solar energy for drying grapes under Egyptian climatic conditions. Misr Journal of Agricultural Engineering, 19 (1), 100-112.
Radwan, S., El-Kholy, M., El-Sheikh, I., & Mousa, S. (2016). Thermal Performance Analysis For Three Different Geometric Shapes Of Greenhouse Type Solar Dryer. Journal of Soil Sciences and Agricultural Engineering, 7(11), 857-863.
Sallam, Y. I.; Aly, M. H.; Nassar, A. F. and Mohamed, E. A. (2015): Solar drying of whole mint plant under natural and forced convection. Journal of advanced research, 6(2), 171-178.
Santos B.; Queiroz M. and Borges T. (2005): A solar collector design procedure for crop drying. Brazilian Journal of Chemical Engineering 22:277-284.
Sekyere, C. K. K.; Forson, F. K. and Adam, F. W. (2016): Experimental investigation of the drying characteristics of a mixed mode natural convection solar crop dryer with back up heater. Renewable Energy, 92, 532-542.
Sreekumar A.; Manikantan P. and Vijayakumar, K. (2008): Performance of indirect solar cabinet dryer. Energy Conversion and Management 49:1388-1395.
Youssef, K. M.; Mokhtar, S. and Morsy, N. (2014): Effect of hot air drying variables on phytochemicals and antioxidant capacity of Jew's mallow (Corchorus olitorius L.) leaves. Suez Canal University Journal of Food Sciences, 2(1), 1-8.
Zakaria, Z. A.; Somchit, M. N.; Zaiton, H.; Mat Jais, A. M.; Sulaiman, M. R.; Farah, W. O.; Nazaratulmawarina, R. and Fatimah C. A. (2006). The in vitro antibacterial activity of Corchorus olitorius extracts. Int. J. Pharm., 2: 213–215. | ||
|
Statistics Article View: 1,185 PDF Download: 684 |
||
