The Role of Renewable Energy in Confronting Climate Change and Reducing the Environmental Impact of the Apparel Industry | ||||
| International Design Journal | ||||
| Article 22, Volume 15, Issue 1 - Serial Number 65, January and February 2025, Page 327-345 PDF (1.4 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/idj.2025.395719 | ||||
 View on SCiNiTO | ||||
| Author | ||||
| Shaima Mustafa Ahmed Muhammad Shehata | ||||
| Assistant Professor, Apparel Department, Faculty of Applied Arts, Helwan University | ||||
| Abstract | ||||
| Time is running out for our resources and our planet, Fossil fuels will soon be depleted, and each day we cause irreversible harm to the environment. The shift to green energy is more urgent than ever, There is a guarantee of the continuous availability of renewable energy, which does not deplete, unlike traditional energy sources. The research problem lies in determining to what extent the use of renewable energy in Apparel factories contributes to environmental preservation and cost reduction. The importance of this research is highlighted by focusing on renewable energy and its benefits, and reducing the environmental pollution caused by conventional energy sources. This research aims to achieve sustainability and climate preservation through the use of renewable energy in Apparel factories, and to reduce electricity consumption costs in these factories. The research hypothesis is as follows: the use of renewable energy preserves the environment and reduces electricity costs in Apparel factories. This research employs a descriptive methodology using analytical techniques to describe and analyze renewable energy and its applicability in Apparel factories. Costs were calculated under three scenarios: electricity-only, On-Grid, and Off-Grid systems. A case study was conducted for Apparel factory producing men's trousers, analyzing The electrical capacity of the factory under study, Solar energy was selected from renewable energy sources because the Arab Republic of Egypt benefits from abundant solar resources. Unlike wind energy, it does not require relocating factory to the desert, as solar energy is readily available and accessible everywhere. To implement this, the factory's rooftop area was calculated for the installation of solar panels, and it was found to be sufficient to cover the required electrical capacity. The following was done Analyzing the calculating energy costs in three cases: The traditional method - using solar energy in two ways (On Grid, Off Grid). The results showed that the costs of the On-Grid system, which amounted to 1.66 million L.E, and the current electricity-only system, which amounted to 1.65 million L.E, were equal after 5 years, assuming that the electricity tariff remains constant. However, since electricity tariffs typically increase periodically, the On-Grid system would become more economically advantageous after five years. It is also important to note that the On-Grid system is more environmentally friendly. The Off-Grid system has a higher cost of 2.84 million L.E due to the high initial cost of solar panels and batteries. When calculating the cost after 30 years, the On-Grid system was found to be the most economical, with a cost of 3.72 million L.E, followed by the Off-Grid system at 5.69 million L.E. The electricity-only system came last, with a significant cost difference of 9.88 million L.E, while also being the most polluting to the environment. We conclude that the most environmentally friendly system is the Off-Grid system, as it relies 100% on solar energy, followed by the On-Grid system, which depends 75% on solar energy. Transitioning to renewable energy is necessary change, because it is a crucial step that can significantly reduce global GHG (Greenhouse Gas emissions), And Confronting Climate Change. | ||||
| Keywords | ||||
| Renewable energy; Apparel industry; Sustainable manufacturing; The Environmental Impact Assessment; Climate change | ||||
|
Supplementary Files
|
||||
| References | ||||
|
1. Alejandro Moreno. (2022). Wildlife Protection and the Clean Energy Transition, Office of Energy Efficiency & Renewable Energy. Retrieved from: https://www.energy.gov/eere/articles/wildlife-protection-and-clean-energy-transition
2. AK Bambam, KK Gajrani. (2023). Challenges in achieving sustainability during manufacturing, Sustainable Materials and Manufacturing Technologies, Taylor & Francis.
3. Apurbo Sarkar, Lu Qian, and Anamika Kor Peau. (2020). Overview of green business practices within the Bangladeshi RMG industry: competitiveness and sustainable development perspective, Environmental Science and Pollution Research.
4. Barakat, Ahmed, and Nasif, Hassan. (2020). The Importance and Role of Renewable Energies Internationally, Journal of Contemporary Commercial and Economic Studies, Vol. (3), No. (2), P.P 87-104.
5. Binoy Debnath, Muntaha Rauf Taha, Md. Tanvir Siraj, Md. Fahmid Jahin, Sazzadul Islam Ovi, A.B.M. Mainul Bari, Abu Reza Md. Towfiqul Islam, Asif Raihan. (2024). A grey approach to assess the challenges to adopting sustainable production practices in the apparel manufacturing industry: Implications for sustainability, Results in Engineering, Elsevier B.V., Volume 22, 102006. Retrieved from: https://www.sciencedirect.com/science/article/pii/S2590123024002597
6. Binoy Debnath, Md Shihab Shakur, Md Tanvir Siraj, A.B.M. Mainul Bari, and Abu Reza Md Towfiqul Islam. (2023). Analyzing the factors influencing the wind energy adoption in Bangladesh: A pathway to sustainability for emerging economies, Energy Strategy, 101265, Elsevier Ltd.
7. Biswas, Mithun Kumar Azad, Abul Kalam, Datta, Anupa, Dutta, Shuvasish;Roy, Shimul, Send mail to Roy S.; and Chopra, Shauhrat S.Send mail to Chopra S.S., (2024). Navigating Sustainability through Greenhouse Gas Emission Inventory: ESG Practices and Energy Shift in Bangladesh's Textile and Readymade Garment Industries, Environmental Pollution, Volume 345, Article number 123392, ISSN 02697491, DOI 10.1016/j.envpol.2024.123392. Elsevier B.V.
https://doi.org/10.1016/j.envpol.2024.123392
8. Brianna Wren. (2022). Sustainable supply chain management in the fast fashion Industry: A comparative study of current efforts and best practices to address the climate crisis, Cleaner Logistics and Supply Chain, Elsevier Ltd.
www.elsevier.com/locate/clsc
9. David Elliott, (2016). Balancing Green Power: How to deal with variable energy sources, IOP Publishing, Bristol, UK.
David Elliott. 2020, Renewables (Second Edition), A review of sustainable energy supply options, IOP Publishing.
Deborah E. de Lange. (2024). Climate action now: Energy industry restructuring to accelerate the renewable energy transition, Journal of Cleaner Production, Elsevier Ltd., Volume 443.
Emily Folkglobal. (2021). What the future of renewable energy looks like, Earth.org. Retrieved from: https://earth.org/the-growth-of-renewable-energy-what-does-the-future-hold/#:~:text=renewable%20energy%20in%20the%20future,electricity%20capacity%20of%20the%20us.
Greg Peters, Mengyu Li, and Manfred Lenzen. (2021).The need to decelerate fast fashion in a hot climate - A global sustainability perspective on the garment industry, Journal of Cleaner Production, Elsevier Ltd.
Gunjan Yadav, Anil Kumar, Sunil Luthra, Jose Arturo Garza Reyes, Vikas Kumar, and Luciano Batista. (2020). A framework to achieve sustainability in manufacturing organisations of developing economies using industry 4.0 technologies’ enablers, Computers in Industry, Elsevier B.V., Volume 122, Article 103280. Retrieved from: https://doi.org/10.1016/j.compind.2020.103280
Halassa, Hanaa and Trayeche, Moamer. (2024). The Impact of Transition to Sustainable Energy on the Environmental Dimension of Sustainable Development in Algeria, Journal of Developmental Studies and Entrepreneurship, ISSN. 2830-988X, Vol. (2), No. (1), P.P 38-58. Harsanto, B., Primiana, I., Sarasi, V.,and Satyakti, Y., (2023). Sustainability Innovation in the Textile Industry: A Systematic Review, Elsevier B.V., All rights reserved, Volume 15, Issue 2 https://doi.org/10.3390/su15021549 Hoque, M.A., Rasiah, R., Furuoka, F., and Kumar, S. (2023). Critical determinants and firm performance of sustainable technology adoption in the apparel industry: the stakeholder approach, Journal of Fashion Marketing and Management, Emerald Publishing Limited, Vol. 27 No. 1, pp. 182-200. Retrieved from: https://doi.org/10.1108/JFMM-06-2021-0147 IPCC (2021). Climate Change: The Physical Science Basis. Contribution of Working Group I to the Sixth Assessment Report of the Intergovernmental Panel on Climate Change, Cambridge University Press. Israt Zahan Mim, Md. Golam Sarower Rayhan, and Md. Syduzzaman. (2024). Prospects and current scenario of industry 4.0 in Bangladeshi textile and apparel industry, Elsevier Ltd., Volume 10, Issue 11, e32044.
Jonathan Koomey and Ian Monroe. (2022). Introduction to the climate problem (short form), Solving Climate Change, IOP Publishing Ltd.
Kaniz Farhana, Kumaran Kadirgama, Abu Shadate Faisal Mahamude, Mushfika Mica. (2022). Energy consumption, environmental impact, and implementation of renewable energy resources in global textile industries: an overview towards circularity and sustainability, Materials Circular Economy, Volume 4(1).
Md Shams Uzzaman, Md. Abul Kashem, Abu Sadat Muhammad Sayem, Adnan Maroof Khan, Sayed Md. Shamsuddin, and Md Mazedul Islam. (2021). Quantifying environmental sustainability of denim garments washing factories through effluent analysis: A case study in Bangladesh, Journal of Cleaner Production, Elsevier Ltd., Volume 290, Article 125740. Retrieved from: https://doi.org/10.1016/j.jclepro.2020.125740
Md. Tareque Rahaman , Arnob Dhar Pranta , Md. Reazuddin Repon , Md. Samin Ahmed , Tarekul Islam. (2024). Green production and consumption of textiles and apparel: Importance, fabrication, challenges and future prospects, Journal of Open Innovation: Technology, Market, and Complexity, Published by Elsevier Ltd on behalf of Prof JinHyo Joseph Yun. Volume 10, Issue 2, 100280. https://doi.org/10.1016/j.joitmc.2024.100280 Md. Ruhul Ferdoush, Ridwan Al Aziz, Chitra Lekha Karmaker, Binoy Debnath, Mohammad Hossain Limon, and A.B.M. Mainul Bari. (2024). Navigating Sustainability of waste-to-energy transition in emerging economies: Implications for sustainability, Innovation and Green Development, Volume 3, Article 100121, Elsevier Ltd.
www.journals.elsevier.com/innovation-and-green-development
MT Siraj, B Debnath, A Kumar, ABMM Bari, A Samadhiya, and SB Payel. (2023). Evaluating barriers to sustainable boiler operation in the apparel manufacturing industry: Implications for mitigating operational hazards in emerging economies, PLOS ONE, Retrieved from: https://journals.plos.org/plosone.
Radi Shafiq. (2024). The Renewable Energy Imperative in Bangladesh: An Apparel Industry Perspective, Environmental Impact of the Global Fashion Industry, Light Castle partners. Retrieved from: https://www.lightcastlebd.com/insights/2024/02/renewable-energy-in-apparel-industry
Rocío Román-Collado, María Teresa Sanz-Díaz, and Luis Yamuza Blanco. (2023). Key drivers of the textile and clothing industry decarbonisation within the EU-27, Journal of Environmental Management, Volume 334, Article 117438. Retrieved from: https://doi.org/10.1016/j.jenvman.2023.117438
Roy, R., Chavan, P.P., Rajeev, Y., Praveenraj, T., and Kolazhi, P. (2024). Sustainable Manufacturing Practices in Textiles and Fashion, in: Muthu, S.S. (ed.), Sustainable Textiles: Production, Processing, Manufacturing & Chemistry, Springer, Cham, pp. 1-22. Retrieved from: https://doi.org/10.1007/978-3-031-51362-6_1
Rupesh Chourasiya , Shrikant Pandey , Rakesh Kumar Malviya , Akshay A. Pujara. (2024). Towards sustainable success: A framework for assessing performance of sustainable manufacturing adoption in Indian textile industry, Sustainable Futures, Published by Elsevier Ltd, Volume 7, 100216 https://doi.org/10.1016/j.sftr.2024.100216 Sajida Kousar, Urooj Shafqat, Nasreen Kausar, Dragan Pamucar, Yeliz Karaca, and Mohammed Abdullah Salman. (2022). Sustainable Energy Consumption Model for Textile Industry Using Fully Intuitionistic Fuzzy Optimization Approach, Comput Intell Neurosci. 2022; 2022: 5724825. Published online 2022.
Samantha Sharpe, Monique Retamal, and Maria Cristina Martinez Fernandez. (2022). Assessing the impact: Environmental impact assessment in the textile and garment sector in Bangladesh, Cambodia, Indonesia and Viet Nam, International Labour Organization (ILO), ISSN: 2708-3446. Saifur Rahman Tushar, Md. Shamsul Arefin Imtiaz, Rafsun Bin Noor, Md. Fahim Bin Alam, A.B.M. Mainul Bari, Abu Reza Md. Towfiqul Islam, Mohammad Mahbub Kabir. (2024). An Intuitionistic fuzzy approach to modeling the drivers to promote Energy-Efficient textile Manufacturing: Implications for sustainable development, Journal of King Saud University - Science, Elsevier Ltd., Volume 36, Issue 6, Article 103214. Retrieved from: https://doi.org/10.1016/j.jksus.2024.103214 Scarlett Buckley. (2022). The Textile Industry’s Transition to Renewable Energy, Fibre2Fashion. Retrieved from: https://www.fibre2fashion.com/industry-article/9496/the-textile-industry-s-transition-to-renewable-energy Şenol Şirin. (2023). Sustainability in manufacturing. Sustainable Materials and Manufacturing Technologies, 1st Edition, CRC Press, Pages 27, eBook ISBN 9781003291961. Tokay, E. (2023). Climate Change, Environmental Philosophy, and Anthropocentrism. In: Pellegrino, G., Di Paola, M. (eds) Handbook of the Philosophy of Climate Change. Handbooks in Philosophy. Springer, Cham. https://doi.org/10.1007/978-3-031-07002-0_107. Weilin Xu, Fu (Jeff) Jia, Lujie Chen, Tobias Schoenherr. (2024). Editorial: Sustainable transition in textile and apparel industry. Journal of Cleaner Production, Volume 443, 141081. https://doi.org/10.1016/j.jclepro.2024.141081. Yingjie Feng, Jingya Wang, Xinyu Ren, Aikong Zhu, Ke Xia, Haiyang Zhang, and Han Wang. (2024). Impact of water utilization changes on the water-land-energy-carbon nexus in watersheds: A case study of Yellow River Basin, China. Journal of Cleaner Production, Elsevier Ltd. Volume 443, 141148. https://doi.org/10.1016/j.jclepro.2024.141148. Yuan-ying Chi, Ruo-yang Li, Jia-lin Li, Shu-xia Yang. (2024). The innovation consumption mode of distributed renewable energy under resource bricolage: A case study of China. Volume 11, June 2024, Pages 1420-1429. https://doi.org/10.1016/j.egyr.2024.01.005. https://www.ecohz.com/sustainability-solutions/clothes-and-shoes https://www.energy.gov/eere/solar/solar-energy-wildlife-and-environment https://www.energy.gov/eere/environmental-impacts-clean-energy#:~:text=Power%20generated%20by%20renewable%20sources,%2C%20species%20loss%2C%20and%20more https://www.energy.gov/eere/renewable-energy https://www.epa.gov/statelocalenergy/local-renewable-energy-benefits-and-resources#:~:text=Environmental%20and%20economic%20benefits%20of,reducing%20dependence%20on%20imported%20fuels | ||||
|
Statistics Article View: 548 PDF Download: 368 |
||||
