DRYING CHARACTERISTICS OF OKRA PODS DURING DRYING PROCESS IN A HOME MICROWAVE OVEN | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 19, Volume 29, Issue 1, January 2012, Page 341-358 PDF (587.18 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2012.102610 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| Abd El-Wahab S. Kassem1; Abdulwahed M. Aboukarima2, 3; Hamza A. Morghany2 | ||||
| 1Proffesor, Agricultural Engineering Department, Faculty of Agricultural, Alexandria University, Egypt. | ||||
| 2Researcher, Engineering Research Institute, Agricultural Research Center, Egypt. | ||||
| 3Assistant Professor at Community College, Huraimla, Shaqra University, P.O. Box 300, Huraimla 11962, Saudi Arabia. | ||||
| Abstract | ||||
| Okra is an important vegetable for different people all over the world. Because of its high moisture content, okra is susceptible to rapid deterioration. The aim of the present work was to determine the effect of a home microwave output powers on drying of okra pods. Okra was dried from initial moisture content of about 89.12% (w. b) to a safe level of about 9.62% (w. b) under different microwave output power levels (75, 150, 300, 500, 700 and 900 W) using the process 1 min ON and switch OFF the microwave oven for 5 min. The obtained data show that, there by increasing the used microwave output powers for drying sample of 100 g, the drying time leading to decrease from 19 to 13 min. To determine the kinetic drying model parameters, the drying data were fitted to four drying models based on the ratio of the final and initial moisture contents versus drying time. Among of the models proposed, the Midilli-Kucuk model gave a better fit for all drying conditions applied. It is expected that this study would be very beneficial to those dealing with the microwave drying systems of the future. | ||||
| References | ||||
|
Adom, K.K., V.P.Dzogbefia and W.O.Ellis.(1997).Combined effect of drying time slice thickness on the solar drying of okra. Journal of the Science and Food Agriculture, 73, 315–320.
AOAC.(1984).Official methods of analysis (14th ed.). Washington, DC: Association of Official Analytical Chemists.
Apar, D., E. Demirhan and G. Dadali.(2009):Rehydration kinetics of microwave-dried okras as affected by drying conditions.Journal of Food Processing and Preservation, 33 (5):618–634.
Brennand, C.P.(1994).Home drying of food. August 1994 (FN-330) http://extension.usu.edu/files/publications/publication/FN-330.pdf
Changrue, V. (2006).Hybrid Osmotic, Microwave-vacuum) Drying of Strawberries and Carrots.Ph.D Thesis, Department of Bioresource Engineering Macdonald Campus of McGill University Ste-Anne-de-Bellevue, Quebec Canada.
Dadali, G.and B.Özbek.(2009).Kinetic thermal degradation of vitamin C during microwave drying of okra and spinach. International Journal of Food Sciences and Nutrition, 60 (1):21-31.
Dadali, G.,D.K.Apar and B. Ozbek.(2007).Microwave drying kinetics of okra. Drying Technology,25 (5):917-924.
Decareau, R.V.(1985).Microwave in the food processing industry. Academic Press Inc., New York, 234 pp.
Demirhan, E.and B.Özbek.(2010).Microwave-drying characteristics of basil.Journal of Food Processing and Preservation, 34 (3):476–494.
Doymaz,I. (2005).Drying characteristics and kinetics of okra. Journal of Food Engineering, 69:275–279.
Grabowski S.and M. Marcotte.(2003). Drying of fruits and vegetables and spices. In: Hand book of postharvest technology: cereals, fruits, vegetables, tea and spices, Chakraverty A., A.S. Mujundar and G.S.V.Raghavan (ed. ) Marcel Dekker, New York: 653-688.
Haghi, A. K. and N. Amanifard.(2008).Analysis of heat and mass transfer during microwave drying of food products. Brazilian Journal of Chemical, Engineering, 25 (3):491- 501.
Henderson, S.M.and S.Pabis. (1961). Grain drying theory I: Temperature effect on drying coefficient.Journal of Agricultural Research Engineering, 6:169- 174.
Inchuen, S., W. Narkrugsa, P. Pornchaloempong, P. Chanasinchana and T. Swing.(2008). Microwave and hot-air drying of Thai red curry paste. Mj. Int. J. Sci. Tech., 1 (Special Issue):38-49.
Kassem,A.S., A. Z. Shokr, A. M. Aboukarima and I. Y. Hamed.(2010).Estimation of moisture ratio of Thompson seedless grapes undergoing microwave drying using artificial neural network and regression models. J. Saudi Soc. For Agric. Sci., 9(1):23-47.
Kassem,A.S., A.Z.Shokr, A. M. Aboukarima and E. Y. Hamed.(2011).Comparison of drying characteristics of Thompson seedless grapes using combined microwave oven and hot air drying.J. Saudi Soc. For Agric. Sci., 10 (1): 33-40.
Kumar, D.and S.Prasad.(2010).Microwave-convective drying characteristics of okra. An ASABE Meeting Presentation, Paper Number: 1008690.
Maskan, M. (2000).Microwave/air and microwave finish drying of banana. Journal of Food Engineering, 44(2):71–78.
Midilli,A., H.Kucuk and Z.Yapar.(2002).A new model for single-layer drying. Drying Technology, 20 (7):1503-1513.
Mohamed, M.A.,G.R.Gamea and M.H. Keshek. (2010). Drying characteristics of okra by different solar dryers. Misr J. Ag. Eng., 27(1):294-312.
Ong, S. P. and C.L.law.(2009):Mathematical modeling of thin layer drying of salak. Journal of Applied Sciences, 9(17):3048-3054.
Ozbek, B.and G. Dadali. (2007). Thin-layer drying characteristics and modeling of mint leaves undergoing microwave treatment. Journal of Food Engineering, 83:541–549.
Page, C.(1949).Factors influencing the maximum rates of air drying of shelled corn in thin layers.Unpublished M.S. Thesis, Purdue University, Lafayette IN.
Sanga, E., A.S. Mujumdar, G.S.V. Raghavan. (2000). Chapter 10: Principles and applications of microwave drying. In: Drying Technology in Agricultural and Food Sciences, A.S. Mujumdar (ed.).Science Publishers, Enfield, USA: 283-289.
Shah, S.and M.Joshi.(2010).Modeling microwave drying kinetics of sugarcane bagasse. International Journal of Electronics Engineering, 2(1):159-163.
Shivhare, U. S., A. Gupta, A. S. Bawa and P. Gupta.(2000).Drying characteristics and product quality of okra. Drying Technology, 18 (1 & 2):409 – 419.
Soysal,Y.(2004).Microwave drying characteristics of parsley. Biosystems Engineering, 89(2), 167–173.
Soysal, Y. (2005). Mathematical modeling and evaluation of microwave drying kinetics of mint (Mentha spicata L. ). Journal of Applied Sciences, 5 (7):1266-1274.
SPSS.(2005).SPSS for Windows Software Version 14.0.
Tontand, S.and N. Therdthai. (2009). Preliminary study of chili drying using microwave assisted vacuum drying technology. As. J. Food Ag-Ind., 2(2):80-86.
Xanthopoulos,G., N.Oikonomou and G. Lambrinos.(2007).Applicability of a single-layer drying model to predict the drying rate of whole figs. Journal of Food Engineering, 81: 553-559. | ||||
|
Statistics Article View: 126 PDF Download: 401 |
||||
