UTILIZING EXHAUST GASES OF DIESEL ENGINES IN DRYING GRAIN RICE | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 17, Volume 28, Issue 4, October 2011, Page 1040-1052 PDF (583 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2011.102618 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| M.A. El-Said Shetawy1; M. H. M. Abo El-Naga2 | ||||
| 1Lect. Agric. Eng. Dept. Fac. of Agric., Al-Azhar Univ. Egypt. | ||||
| 2Sen. Res., Ag. Eng. Res. Inst., Ag. Res. Center, Dokki, Giza, Egypt. | ||||
| Abstract | ||||
| In Egypt, rice crop occupies the first rank in area cultivated as the main food.Percentage of moisture in grain is up to 24% with mechanical harvesting of rice crop. For safe storage of rice seeds, it is required to reduce the humidity to 14%. Due to weather changes it is difficult to dry by the sun. Therefore, the main objective of this study is the use of thermal energy lost with the exhaust gases of diesel engines in drying rice seed. The suggested drying unit is simple made from local raw materials, comprising: a fan to generate air stream carry the heat, heat exchanger for the exhaust gases installed behind the fan, a drying container. Drying tests were conducted using the Sakha 101, whereas the average weight of each sample in drying process was 25 kg, the average humidity was 20.4%, the average temperature of air was 24.6 oC and the average relative humidity of the air was 65.7%. The experiments have shown the following results: The highest temperature of input drying air was 42.2 oC, energy received by drying air was 9.62 MJ/h and capacity of drying unit was 0.074 ton/h achieved with drying air flow rate o7.65 m3/min. | ||||
| References | ||||
|
Abe, T., C. E. Ofoche, Y. Hikida and J.Yamashita (1992). Utilization of engine-waste heat for grain drying. Proceedings of the International Agricultural Engineering Conference, Bangkok, (IV), 1147-1154.
ASAE yearbook standard (1983).Pub. by the Am. Soc. of Ag.Eng.,St. Joseph, Mich., USA.
Basunia, M. A., T. Abe, and Y. Hikida. 1996a. Simulation of engine wasted heat stationary-bed rough rice dryer. Agricultural Mechanization in Asia, Africa and Latin America, 4(27): 37-45, 48.
Basunia, M. A. and T. Abe. 1996b. Energy savings in intermittent drying of rough rice using engine waste heat. Agricultural Engineering Journal, 5(3 & 4): 149-159.
Basunia, M. A. Abe, T. and Y. Hikida (1997). Utilization of engine-waste heat for paddy drying and validation of stationary-bed model invariable low temperature drying. AMA: Africa and Latin Am., 28 (4), : 47-52.
Basunia, M.A and T. Abe (2008). Performance study of a small engine waste heated bin dryer in deep bed drying of paddy. Ag. Eng. I: the CIGR Ejournal Manuscript EE 08 015. Vol. X. Dec., 2008: 1- 11.
Brooker, D. B.; F. W. Baker – Arkema and C. W. Hall (1978). Drying cereal grain. 2nd Ed. AVI pub. Co., Westport, Conn., INC., USA.:
Li, H. and R. V. Morey (1984). Thin-layer drying of yellow dent corn. Trans. ASAE: 581-585.
Ojha, T. P. and Michael, A. M. (1996). Principles of Agricultural Engineering., Vo. I, 3 rd Edi. Jain Broth., New Delhi, India.
Michael, A. M. and T. P. Ojha (1978).Principles of agricultural engineering, Vol. 1, Farm power and machinery, Farm building and post – harvest technology. 873, East Park Road, Koral Bagh, New Delhi – 110005.
Shamim Akhter, Md., Md. Nurun Nabi and Zakia Afroz (2007). Recovery of waste heat from engine exhaust for utilization in a paddy dryer (ICME2007) December 2007, Dhaka, Bangladesh.: 29- 31.
Soemangat, M. L. Esmay and W. J. Cahanceller (1973). Rice drying with engine waste heat. AMA: in Asia, Africa and Latin Am., A., : 80-85. | ||||
|
Statistics Article View: 102 PDF Download: 235 |
||||
