CHARACTERISTICS IMPROVEMENT OF BUILDING MATERIALS FABRICATED FROM AGRICULTURAL RESIDUES | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 22, Volume 27, Issue 4, October 2010, Page 1365-1380 PDF (772.61 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2010.104843 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
Mohamed Fayed A. Khairy 1; M.A. MOSALLAM2; R.R. EL-BESSOUMY3
| ||||
| 1Ag. Eng. Dept., Faculty of Ag., Al-Azhar U., Cairo, Egypt. | ||||
| 2Ass. Prof. Of Ag. Eng. Dept. of Ag. Eng., Fac. of Ag. (Cairo), Al–Azhar U., Egypt. | ||||
| 3Ass. Lect., Ag. Eng. Dept. of Ag. Eng., Fac. of Ag. (Cairo), Al–Azhar U., Egypt. | ||||
| Abstract | ||||
| For improving the qualities of the straw brick (as control), three waste materials and sand were used to replace partially the straw. The waste materials are rubber, glass and mix of rubber and glass. The replacement ratios were 15, 30 and 45 % by weight basis. After carrying out the replacements, the bricks were tested for each of the following characteristic: bulk density, water absorption percentage, compressive stress, thermal conductivity and acoustical insulation percentage. Generally the resulted bricks were superior for the previously mentioned characteristics than the control brick. Replacing sand into the straw brick (control) resulted in less water absorption; less thermal conductivity and more acoustical insulation percentage while replacing a mix of glass and rubber resulted in more compressive stress in comparison with the control brick. | ||||
| References | ||||
|
Alaa El-Dine, M.N.; S.A. El-Shimi; M.H. Mahmoud and A.M. Abdel Aziz, (1983). Biogas for Egyptian villages (Energy - feltilizer - forage) Soil and water research institute, Agri. Research Center, :257 (in Arabic).
Corinaldesi, V.;G. Gnappi; G. Moriconi and A. Montenero, (2005). Reuse of ground waste glass as aggregate for mortars, Waste Manage, 25 (5): 197-201.
FAO (Food and Agriculture Organization of the United Nation) (2005). Quarterly bulletin of statistics, New York. (c.f. Moussa,2008).
Hermansson, L.A.,(1993). Cement-Bonded straw slabs, Feasibility study, Building Issues, 5(2): Lund University, Lund, Sweden. (c.f. Mansour et al.,2007).
Kazragis, A.,(2005). Minimization of atmosphere pollution by utilizing cellulose waste, Journal of Environmental Engineering and Landscape Management, 13(2): 81-90.
Mansour, A.; J. Srebric; and B.J.Burley,(2007). Development of straw-cement composite sustainable building material for low-cost housing in Egypt, Journal of Applied Sciences Research, 3(11): 1571-1580.
Moussa, I.A.,(2008). Effect of some adhesive matter on agricultural wastes as building materials, MSc., Thesis, Ag. Eng. Dept., Faculty of Agriculture, Al-Azhar University.:4,20,23.
Noakes, G.R.; A.M. Oxon and F.Inst, (1953). Text-Book of heat, Macmilan and Co., Liwnrled, London, : 337-338.
Shayan, A., (2004).Value-added utilization of waste glass in concrete, Cem. Concr. Res., 34 (1):81-90.
Staniforth, A., (1979). Cereal straw, Clarendon Press., Oxford. (c.f. Moussa,2008)
Sukontasukkul, P., (2009). Use of crumb rubber to improve thermal and sound properties of pre-cast concrete panel, Construction and Building Materials, 23(2): 1048-1092.
Suliman, A.E. and A.M. El-Zahaby, (1998). Utilization of some field crops residues, 1st international conference on Rationalizate of Energy in Agriculture Ag. Mech. Dep., Faculty of Agriculture, Mansoura Univ. 17-18 March, 1998 : 173-187.
Turgut, P., (2008). Properties of masonry blocks produced with waste limestone sawdust and glass powder, Construction and Building Materials, 22(7):1422-1427.
Yang, S.H.;D. Kim; Y. Lee;H. Kim; J. Jeon and C. Kang, (2004). Possibility of using waste tire composites reinforced with rice straw as construction materials, Bioresource Technology, 95(1): 61-65. | ||||
|
Statistics Article View: 162 PDF Download: 229 |
||||
