SELECTION OF THE MAIN FACTORS AFFECTING CLEANING AND GRADING FENNEL SEEDS AT INCLINED SIEVE OSCILLATION | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 13, Volume 27, Issue 2, April 2010, Page 628-643 PDF (655.53 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2010.105933 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| Salwa .S. Hanna; ٍShaaban M. Ahmed; Nasser M. El_Ashmawy | ||||
| Researcher, Agric. Eng. Res. Inst., Agric. Rec. Center, Egypt. | ||||
| Abstract | ||||
| Nowadays, the world considers the medicinal and aromatic plants as natural alternative to the chemical drugs because it has no side effects. Moreover, there is a difficulty for any country to achieve self- sufficient of chemical drugs. Fennel is considered one of the most important medicinal and aromatic plant in Egypt. Commercial fennel varies greatly in quality, this being due to the lack of care during harvesting. Also, the presence of impurities in seeds decrease in the quality and standardization. So the use of grain cleaning and grading equipment is important for cereal producer as an aid to marketing his product. An experimental cleaning machine was development. The slope of the sieve unit, air velocity, crank speed and stroke length could be adjusted easily as required. The cleaning unit was tested under the following main factors (the crank speed of the sieve unit, stroke length, and slope of the sieve unit). Seeds were graded by the machine, into three categories, collected at three separate outlets. The maximum cleanliness obtained for grade one, two ,and three were 99.15,98.74 and 83.65 % respectively, and obtained at crank speed of 250 rpm, amplitude 20mm, sieve slope 8.5 degrees, and air velocity 2.7 m/s. The maximum effectiveness of the unit was 78.8%. | ||||
| References | ||||
|
Abd El – Tawwab, I. M. ; M. A. Baiomy and S.El-Khawaga.2007. Design and fabrication of a local rice separating machine. J. Agric. Sci. Mansoura Univ.,32 (7) :5355-5368.
Awady,M. N.,I. Yehia, M.T. Epaid, and E.M. Arif.2003. Development and theory of rice cleaner for reduce impurities and loses .Misr. j. Ag. Eng. ,20(4) :53-68.
E. E. D. C. 1987. Egyptian Exporter Development Center, Giza, Egypt
E. E. D. C. 1998. Egyptian Exporter Development Center Giza, Egypt.
Elliot, W., B. D. Adam, P. Kenkel, and K. Anderson. 1998. Can the grain marketing system provide sufficient quality incentives to producers? NCR-134 Conference on Applied Commodity Price Analysis Forecasting, and Market Risk Management. Chicago, IL.
Ebaid,M. T. 2005. Effect of physical properties of wheat on cleaner performance. Misr. J. Ag. Eng., 22(1):127-144.
Feller, R. 1980. Screening analysis considering both passage and clogging . Trans. ASAE, 23(4) : 1054 - 1056.
Hanna,S.S.2003. Construction and development of cleaning unit suitable for medicinal and aromatic seed crops Ph.D. Thesis. Faculty of agriculture, Kafr El- Sheikh,Tanta University.
Ismail, F. H. 1986. Engineering and technological study on cleaning and grading crops. M.Sc. Thesis ,Faculty of Agricultural Mansoura University, Maunsoura, Egypt.
Kashayap, M. M. and A. C. Pandya.1965. A Study of winnowing indices. J.Agric. Eng. Res. , 10(3): 255 – 258.
Negrini, O. ; C. K. Spillman ; Y. J. Wang ; D. S. Chung ; J. L. Steele, and E. Posner. 1994. Evaluation of laboratory grain cleaning and separating equipment. Part II. Transactions of the ASAE, 37 (6): 913 – 918.
Perry, R. H., and C. H. Chilton. 1973. Chemical Engineers’ Handbook. Mc Graw- HILL KOGAKUSHA, LTD. Fifth Edition.
Sahay, K. M., and K. K. Singh.1994. Unit Operations of Agricultural Processing. VIKAS Publishing House PVT, LTD, New Delhi, First Edition.
Wang, Y. J. ; D. S. Chung ; C. K. Spillman ; S. R. Eckhoff ; C. Rhee, and H. H. Converse. 1994. Evaluation of laboratory grain cleaning and separating equipment. Part I. Trans. ASAE, 37 (2) : 507 – 513.
المراجع العربیة وزارة ألاقتصاد والتجارة الخارجیة.1991. النشرة الاقتصادی | ||||
|
Statistics Article View: 227 PDF Download: 237 |
||||
