A NEW NETWORK DESIGN FOR FORCING AIR TO PRODUCE COMPOST | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 19, Volume 27, Issue 2, April 2010, Page 718-736 PDF (636.82 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2010.105939 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| M.A.M. Ahmed1; M.Y. El.Ansary2; M.A. Awad2; M.T. Afify2 | ||||
| 1Agric. Eng. Res. Inst., Agric. Res. Center, Egypt. | ||||
| 2Dep. of Agric. Eng. Fac. of Agric., Benha U., Egypt. | ||||
| Abstract | ||||
| The large amounts of the agricultural wastes remaining after the harvesting operations of the different crops represent a great challenge facing farmers, where they are estimated at 25 million tons annually. The farmers have to burn these wastes. This behavior leads to serious problems including the air pollution. Composting is considered the other choice to get rid of the agricultural wastes. It aims at both conservation of the environment, human safety and economically convenient production. The current investigation aims at: 1- Designing a network for forcing air through the compost pile to facilitate production of a good compost. 2- Studying the effect of both type of tube and rate of forcing air through it on the end-product, i.e. the compost beside of saving labor and time of production. A direct ventilation system has been designed. It works on the basis that there is no turning but through forced air for the purpose of producing the compost from a mixture of rice straw and cattle dung at ratio of 2:1. For fulfilling these purposes four networks were designed as follows: 1- Transversal system. 2- Longitudinal system. 3- Width and length system. 4- Reciprocal system. The whole system was designed using PVC pipes with a 6.35 cm diameter, 3.9 mm thickness, a 262 cm length and a 130 cm width. The length and width were drilled with holes at equally divided distances of 30 cm (center to center) in two parallel rows. The used types of tubes and the rate of air forced through them were evaluated according to the compost quality standards and guidelines which depend on determining quality parameters of the compost to be used in agriculture. The obtained results indicated that the most suitable design for a network to produce compost of acceptable quality is the "width and length system" within which air is forced at rate of 0.0196 m3/min.Moreover, a comparative study conducted among this system and both of natural conveyance system and self propelled machine systems illustrated that although the natural conveyance method gave the highest profit, yet the system depended on forcing air through width and length system seemed more preferable owing to the more favorable quality of the compost obtained by this method and also its relatively high profit. | ||||
| References | ||||
|
Abbas, H.H., E.H.A. Noufal, I.M. Farid and I.M.E. Ali (2006) Organic manuring and bio – fertilization approaches as potential economic and safe substitutes for mineral nitrogenous fertilization. Egypt. J. Soil Sci., 46 (2):219 – 135.
Abbas, H.H., I.M.Farid and Ali, M.M.E. (2010) Growth of maize and its uptake of some macro and micronutrients under different untraditional fertilization treatments. Minia 2nd Conf. Agric. Environ. Sci., March 22-24,2010.
Abd-ElMottaleb,A.F. and Kotob,M.M.(2005)''Engineering and economical studies on compost agitation systems under Egyptian conditions '' Misr J. Ag. Eng., 22(2): 612 – 634.
Ahmed, A. M. (2010) "Study of compost application for clay soil under surface and subsurface drip irrigation systems" undergoing Ph.D. Th., Ag. Eng., Fac. Ag. Benha U.
ASAE, standards D241.4 (1997) "Methods of determining density, specific gravity, and mass moisture" ASAE st. Joseph, Michigan.
Bitton G. (1999). Public health aspects of wastewater and sludge disposal, p. 347. In Bitton G (ed.) Wastewater microbiology. JohnWiley & Sons Inc.,New York.
Conti, F., Urbini, G., Zorzi, G. and Bertoldi,M. de(ed.)(1996) Basic processing technologies and composting plant design in Italy.The Sci. composting: part 2,: 958-972.
Das, K. and Keener, H.M. (1997) " Numerical Model for the dynamic Simulation of large scale composting system" Transaction of the ASAE, 40 (4):1179-1189.
Eldridge, R.; Collins, J. and Shan, C.P. (1993) "Development of composting recipe for swine. Presentation at I. summer Mtg. sponsored by ASAE, Spokane center, Washi., paper no.934033.
Hansen, R. C. , Keener, H. M. and Hoitink, H. A. J. (1989).''Poultry manure composting. An exploratory study''.Trans. ASAE, 32 (6) : 2152 – 2157 .
Hatem, M. H.; and Gay , A. E. (1994). '' composting of municipal solid waste '' Misr, J. Agric. Eng., 11 (2) : 548 – 558.
Hong, J. H.; Park, K. J. and Sohn, B. K.(1997). '' Effect of composting heat from , intermittent aerated static pile on the elevation of underground temperature ''. Appl. Engi. Ag.. Vol. 13 ( 5 ) : 679 - 683.
Hong , J. H. ; Matsuda , J. and Ikeuehi , Y. ( 1985 ) '' An overview of compost maturity during solid composting in mixture of dairy manure and crop residues ''. Soci. Ag. Structures, Japan, 16 ( 1): 6 – 13 .
Inbar, Y. , Hadar, Y. and Chen, Y. (1993). ''Recycling of cattle manure: The composting process and characterization of maturity''. Environ. Qua., (4): 857 – 863.
Merkel, J.A. (1981). ''Managing livestock wastes'' AVI Publ.Co., Westport Conn. : 306-324.
Martin, D. L. and G. Gershung (1992) The Rodale Book of composting. Rodal press, Emmaus, Pennsylvania.
Rynk, R. (1992). " On-farm composting handbook", Northeast Reg. Agr. Eng. Service, Ithaca, N. Y. :54
Seki, H. (2000). '' Stochastic modeling of composting processes with batch operation by the Fkker – Plant equation Trans. ASAE, 43 (1): 169 – 179.
Sartaj, M.; Fernandes, L. and Patni, N.K. (1995). '' Influence zone of aeration pipes and temperature variations in passively aerated composting of manure slurries Trans. ASAE, 38 (6): 1835 – 1841.
Sartaj, M.; Fernandes, L. and Patni, N.K.(1997). Performance of forced , passive , and natural aeration methods for composting manure slurries. Trans. ASAE, 40 ( 2 ) : 457 – 463 .
Walker, L. P.; Nock, T. D.; Gossett, J. M. and VanderGheynst, J. S. (1999). '' The role of periodic water addition in managing moisture limitations during high–solids aerobic decomposition '' Process Biochem., 34 (6-7): 601 – 612. | ||||
|
Statistics Article View: 92 PDF Download: 134 |
||||
