IDENTIFY SUITABLE HYDRAULIC FACTORS FOR CONTROL RAISE AND LOWER LASER SCRAPERS | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 2, Volume 26, Issue 4, October 2009, Page 1682-1695 PDF (207.37 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2009.107372 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| S. I. El-Katib1; S. F. M. Eid2; H.E. Osman3 | ||||
| 1Senior Res., Agric. Eng., Res. Ins., Agric. Res. Center, MOA, Cairo, Egypt. | ||||
| 2Res., Agric. Eng., Res. Ins., Agric. Res. Center, MOA, Cairo, Egypt. | ||||
| 3Deputy, Agric. Eng., Res. Ins., Agric. Res. Center, MOA, Cairo, Egypt. | ||||
| Abstract | ||||
| The present work was carried out in private farm at Hoash Essa – Behera governorate during agriculture season of 2008 in clay soil. The aim of this experiment is to study the relation between the tractor hydraulics, hydro-electric valves, scraper cylinder, raise and lower scraper paled, scraper load and their effects on the laser land leveling efficiency. An area of (6 feddans) was divided into 2 plots; each plot was leveled with different scraper. Two scrapers were used 3 and 3.6 m width (10 and 12 feet). Each plot was surveyed and calculated the volume of cut (m3). The hydraulic of oil pressure (bar) and hydraulic of oil flow rate (l/min) were measured with the scraper raise (every 0.5 cm) and computed the volume of soil fill (m3). Also, the actual capacity of scrapers volume m3, amount of earth moving m3/h and laser efficiency were calculated. The results showed that, actual scrapers loaded were 69 and 70.50 % (from theoretical loaded) with 3 and 3.6m scraper width, respectively. Maximum pressure needed to raise scraper was 52 and 110 bar with 3 and 3.6m scraper width, respectively. Maximum oil flow rate was 18.5 and 38.00 l/min. with 3 and 3.6m scraper width respectively. Scrapers field capacities were 10.88 and 16.96 m3/h with 3 and 3.6m scraper width, respectively. Every cubic meter of soil needed to 52 bars and 18.5 l/min. oil flow rate to fill area 25 m2 with 4 cm depth. The scraper capacity efficiency increased by increasing cutting depth, it was increased from 6.94 to 69.44% by increasing cutting depth from 0.5 to 4 cm for 3 meter scrapers width also it was increased from 4.63 to 70.73% by increasing cutting depth from 0.5 to 4 cm for 3.6 meter scrapers width. The predicted equations help engineering computer designers to make decision easily and determine the actual hydraulic oil pressure and oil flow rate to move the amount of earth. | ||||
| Keywords | ||||
| The hydraulic oil pressure; oil flow rate; raising and lowering scraper paled | ||||
| References | ||||
|
Black, C. A., D. D. Evans, L. E. Ensminger, and R. C. Dinauer, (1965). Methods of analysis (part 1). Am. Soc. of Agron., Inc. Publ. Madison, Wisc., U.S.A.
CPTI (1999). Manual for Laser Leveling. Cambodia Project Tractor Implement, International Rice Research Institute. Agric. Eng. Division LOSBANOS, LAGUNA, PHILIPPINS. pp 7-8.
El-Khatib, S. I. (1992). Effect of degree of accuracy of land leveling on performance and efficiency of some farm machinery. M. Sc. Thesis Faculty of Agric. Ain Shams Univ., Egypt. Pp 50-51.
El-Hammamy, A. A. (1988). Precision land leveling: An effective tool from on-farm water management. First conference on irrigation improvement Cairo, Egypt.
El-Sayed, S. G.(2004). A study on Increasing the Laser Unit Efficiency under Egyptian Condition. M. Sc. Thesis Fac. of Agric., Zagazig Univ., Egypt. Pp 56-57.
Gabber, K. A. E. (2001). Precision land leveling by using laser technology under the conditions of Fayoum Governorate. M. Sc. Thesis, Soils and Water Dept., Fac. of Agric. at Fayoum, Cairo Univ., Egypt. Pp 60-61.
Jensen, M. E. (1980). Design and operation of farm irrigation systems. The Transaction of Amer. Sec. Agric. Eng. Vol 23.
Mostafa, M.M., EL-Gindy, A., Saif-Elyazal M.N. and El-Khatib, S.I. (1993). Laser land leveling efficiency and power requirements. International conference on technological techniques for handling agricultural products 5-10 April 1993. Cairo Uni.Cairo, Egypt pp 58-75.
Zayed. M. F. (2005). Modification of laser technology in farm application. M. Sc.Thesis, Fac. of Agric., Mansoura Univ., Egypt. pp 83-84. | ||||
|
Statistics Article View: 111 PDF Download: 170 |
||||
