ECONOMIZATION INTENSIVE OUTDOOR MASS PRODUCTION OF THE GREEN ALGA SCENEDESMUS SP. | ||||
| Egyptian Journal of Phycology | ||||
| Article 14, Volume 8, Issue 1, 2007, Page 195-206 PDF (457.8 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/egyjs.2007.114563 | ||||
 View on SCiNiTO | ||||
| Author | ||||
| Abo El-Khair Badawy El-Sayed | ||||
| Fertilization Technology Department, National Research Centre, Cairo, Egypt | ||||
| Abstract | ||||
| The green alga Scenedesmus sp. was out door scaled-up within three cement open ponds with a final capacity of 15m3 for each one. The used nutrient solution was composed of tap water enriched by macronutrients (NPK) from commercial sources. Dilution of cultures was done according to growth rate and nutrients supplementation as growth reached their maximum dry weight. Continuous centrifugation was carried out at the end of each batch and the obtained biomass was calculated. A comparison was performed; during long term successive season; as growth was employed under the recommended amount of NPK. It was found that electric power represented the maximum cost and the net cost was found in contrast with the volume of growth unit. In addition, enriched growth medium by extra amount of urea and micronutrients led to yield maximization. Maximum cost was observed during inoculums preparation and the lowest cost was found with cultures grown in large scale. | ||||
| References | ||||
|
Abdel-Maguid, A. A.; El-Sayed, A. B. and Hassan H. S. A. (2004). Growth enhancement of olive transplants by broken cells of fresh green algae as soil application. Monoufiya J. Agric. Res., 29(3): 723-737.
Allison. R. K.; Skipper, H. E.; Reid, M. R.; Short, W. A. and Hagan, G. L. (1954).Studies on photosynthesis reaction. II. Sodium formate and urea feeding experiments With Nostoc muscorum. Plant Physiol., 29:164-172.
Borowitzka, M. A. (1999).Commercial production of microalgae: ponds, tanks, tubes and fermentors. J. Biotechnol., 70:313-321.
Borowitzka, M. A. (1992).Algal biotechnology products and processes - matching science and economics. J. Appl. Phycol., 4: 267-279.
Del Campo, J. A.; García-González, M. and Guerrero, M. G. (2007).Outdoor cultivation of microalgae for carotenoid production: current state and perspectives. Appl. Microbiol. Biotechnol., 74:1163-1174.
El-Sayed, A. B. (1995). Physiological studies on some fresh water green algae. M.Sc. Thesis, Faculty of Agric., Department of Agriculture Botany, Moshtohor, Zagazig University, Egypt.
El-Sayed, A. B. (1999). Some physiological studies on green algae. Ph.D. Thesis, Faculty of Agric., Department of Agriculture Botany, Cairo University, Egypt.
El-Sayed, A. B. (2004a). Screening and growth characterizations of the green life stock of drill water from Jeddah, Saudi Arabia. I. Isolation and growth characteristics of Scenedesmus sp. New Egypt J. Microbiol., 8:376-385.
El-Sayed, A.B. (2004b). Circulation of Quaron Lake wastes. II. Growth of Scenedesmus sp. under Mg residences. Egypt. J. Biotech., 17(2): 477-485.
El-Sayed, A. B. and Abdel-Maguid, A. A. (2005).Screening and growth characterization of the green life stock of drill water from Jeddah, Saudi Arabia. III- Enhancement of secondary carotenoids by oxidative stress in relation to medium composition. New Egypt J. Microbiol., 10:232-241.
El-Sayed, A. B.; Abdalla, F. E. and Abdel-Maguid, A. A. (2001). Use of some commercial fertilizer compounds for Scenedesmus cultivation. Egypt. J. Phycol., 2: 9-15.
El-Shafey, Y. H.; El-Fouly, M. M.; Khalil, M. M.; Abdallah, F. E. and El-Sayed, A. B. (1999). Secondary carotenoids accumulation by some green algae species. The First Congress on the Recent Technologies in Agriculture, 27-29 Nov., 1999; Faculty of Agriculture, Cairo University, Egypt.
Gudin, C. and Chaumont, D. (1980).A biotechnology of photosynthetic cells based on the use of solar energy. Biochem. Soc. Trans., 8:481- 482.
Khalil, A. I.; El-Ayouty, E. Y.; El-Husseiny, O. and El-Asadi, M. A. (1979).Nitrogen metabolism of Chlorella vulgaris as affected by feeding with ammonium chloride with or without pyruvate. Egypt. J. Physiol. Sci., 6(1-2):134-148.
Molina-Grima, E.; Acién Fernández, F. G.; García Camacho, F. and Chisti, Y. (1999).Photobioreactors: light regime, mass transfer and scale-up.J. Biotechnol., 70:231-247.
Pribil, S. (1970).Mineral nutrition of algae. Ann. Report Lab. Algol. Czechoslovak Acad. Scien., Trebon.
Pulz, O. and Gross, W. (2004).Valuable products from biotechnology of microalgae. Appl. Microbiol. Biotechnol., 65:635-648.
Richmond, A. (2004). Handbook of microalgal culture. Biotechnology and applied phycology. Blackwell Science, Oxford, UK.
Syrett, P. J. (1963).The assimilation of ammonia by nitrogen starved cells of Chlorella vulgaris. Part I. The correlation of assimilation with respiration. Ann. Bot., 17:1-19.
Tredici, M. (2004).Mass production of microalgae: photobioreactors. In: Richmond A (ed) Handbook of microalgal culture. Blackwell Science, Oxford, UK, pp 178–214.
Weissman, J. C.; Goebel, R. P. and Benemann, J. R. (1988).Photobioreactor design: mixing, carbon utilization, and oxygen accumulation. Biotechnol. Bioeng., 31:336-344.
Xi, G. and Feng, C. (1998). Influence of medium composition on astaxanthin content and production of Haematococcus pluvialis. Process Biochem., 33(4):365-363.
Zaborsky, O. R. (1985).Feeds from Spirulina: Process Engineering and genetic engineering analysis of co-products. (OMEC International, Inc. Washington D.C). | ||||
|
Statistics Article View: 99 PDF Download: 102 |
||||
