Pharmaceutical wastewater treatment using free and immobilized Cyanobacteria | ||||
| Egyptian Journal of Phycology | ||||
| Article 6, Volume 20, Issue 1, 2019, Page 123-154 PDF (757.6 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/egyjs.2019.116025 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| E. F. Shabana; H. H. Senousy; E. B. Khourshid* | ||||
| Botany and Microbiology Department, Faculty of Science, Cairo University, Egypt. | ||||
| Abstract | ||||
| An attempt has been made to study the feasibility of pharmaceutical wastewaters (laboratories waste (WI) and production waste (WII)) treatment using free and immobilized cyanobacterium Phormidium fragile. After preliminary test with different concentrations, WI showed high toxicity, only 0.5% conc. was effective while WII was used at high conc. of 40% after 10 days incubation (from growth curve experiment) in optimum growth conditions. Role of Phormidium cellsin bioremediation of pharmaceutical wastewaters was effective whereas maximum percentage removal in tested parameters were 51.56% and 58.89% for ammonia, 66.67% and 61.23% for phosphorus, 51.74% and 54.55% for COD and 37.05% and 59.85% for BOD in WI and WII respectively with respect to treatments without microalgae. N-starvation for 36 hours prior to cultivation caused increase in percentage removal of ammonia, phosphorus and COD with increase in algal dose than unstarved cells, 100%, 100% and 72.56% for WI and 87.28%, 100% and 71.98% for WII, respectively with 40 ml algal dose. It was found that 2500 lux and 25 ºC were the best for nutrients removal. Chlorophyll a, dry weight, protein and total carbohydrate contents were also estimated. During this study, pH levels increased and remained in the range 7.3 to 9.1. Significant removal of ammonia, phosphorus and COD were observed in algal alginate beads treatments than blank beads. Starvation before immobilization recorded the highest removal percentage when compared to unstarved beads or free cells in both wastes types and their mixture (1:1). When starved and unstarved Phormidium beads were incubated in WI, WII and a mixture of both in a semi-continuous system for five consecutive cycles (10 days each), there was increase in nutrients percentage removal up to the third cycle. Microalga in the beads survived long enough which gives a promise to upgrading immobilization technique for wastewater treatment with low cost. | ||||
| Keywords | ||||
| Cyanobacteria; Phormidium; Pharmaceutical wastewater treatment; starvation; immobilization; alginate beads | ||||
| References | ||||
|
Abdel Hameed, M. S. (2002).Effect of Immobilization on growth and photosynthesis of the green alga Chlorella vulgaris and its efficiency in heavy metals removal. Bull. Fac. Sci. Assiut Uni., 31(1-D): 233-240.
Abdel Hameed, M. S. (2007). Effect of algal density in bead, bead size and bead concentrations on wastewater nutrient removal. African Journal of Biotechnology., 6 (10):1185-1191.
Abdulsada, Z. K. (2014). Evaluation of microalgae for secondary and tertiary wastewater treatment. Master Thesis, Ottawa-Carleton Institute for Environmental Engineering Ottawa, Ontario, pp. 114. Amin, A.; Naik, A. T. R.; Azhar, M. and Nayak, H. (2013). Bioremediation of different waste waters—a review. Cont. J. Fish. Aquat. Sci., 7(2):7–17.
Amiri, R. and Ahmadi, M. (2019). Treatment of wastewater in sewer by Spirogyra sp.green algae: effects of light and carbon sources. Water and Environment Journal., 33: 1-11.
APHA (2012). Standard Methods for the Examination of water and wastewater, 22nd Edition. American Public Health Association, American Water Works Association and Water Environment Federation, Washington, DC. USA.
Azeez, R. A. (2010). A Study on the effect of temperature on the treatment of industrial wastewater using Chlorella vulgaris Alga. Eng. Tech. J., 28(4):1-8.
Bechet, Q.; Laviale, M.; Arsapin, N.; Bonnefond, H. and Bernard, O. (2017). Modeling the impact of high temperatures on microalgal viability and photosynthetic activity. Biotechnol Biofuels., 10:136.
Bikram, B.; Biswanath, B. and Apurba, D. (2014). Studies on the potential use of sugarcane bagasse as carrier matrix for immobilization of Candida tropicalis PHB5 for phenol biodegradation. Int. Biodeter. Biodegrad., 93:107–117.
Boominathan, M. (2005). Bioremediation studies on dairy effluent using cyanobacteria, Ph.D. Thesis, Bharathidasan University, Tiruchirapalli, Tamil Nadu, India, pp.1-92.
Borowitzka, M. A. (1998). Limits to growth, in Wastewater treatment with algae, Wong, Y. S. and Tam, N. F. Y. Editors. Springer Verlag. p. 203–226.
Butterwick, C.; Heaney, S. I. and Talling, J. F. (2005).Diversity in the influence of temperature on the growth rates of freshwater algae, and its ecological relevance. Fresh w. Biol., 50(2):291–300.
Campos-Rudin, M. and Silva-Benavides, A. M. (2018).Ammonium and phosphate removal using batch laboratory cultures by microalgae and cyanobacteria isolated from Costa Rica water bodies. Int. J. Trop. Biol., 66(1): S83-S91.
Cassidy, M. B.; Lee, H. and Trevors, J. T. (1996). Environmental applications of immobilized cells: a review. J. Ind. Microbiol., 16:79–101.
Chaney, A. L. and Marbach, E. P. (1962). Modified reagents for determination of urea and ammonia, Clin.Chem., 8(2): 130-132.
Clark, J. M. and Switzer, R. L. (1977). Experimental Biochemistry. W. H. Freeman, Company San Francisco (Eds.) (2nd edition), P 4.
Cruz, I.; Bashan, Y.; Hernandez-Carmona, G. and De-Bashan L. E. (2013). Biological deterioration of alginate beads containing immobilized microalgae and bacteria during tertiary wastewater treatment. Appl. Microbiol. Biotechnol., 97:9847–9858.
Daliry, S.; Hallajsani, A.; Mohammadi Roshandeh, J.; Nouri, H. and Golzary, A. (2017).Investigation of optimal condition for Chlorella vulgaris microalgae growth. Global J. Environ Sci Manage., 3(2):217–30.
De la Noüe, J. and Proulx, D. (1988). Tertiary treatment of urban wastewater by chitosan-immobilized Phormidium sp. In Algal Biotechnology. (Edited by Stadler, T. et al., Elsevier Applied Science, New York, pp. 159–168.
Dixit, D. and Parmar, N. (2013). Treatment of pharmaceutical waste water by electro-coagulation and natural coagulation process: review. VSRD Int. J. Technol. Non Technol. Res., 4(5):79–88.
Dubey, S. K.;Dubey, J.; Mehra, S.; Tiwari, P. and Bishwas, A. J. (2011). Potential use of cyanobacterial species in bioremediation of industrial effluents. Afr. J. of Biotechnol., 10 (7):1125-1132.
Dubois, M.; Gilles, K. A.; Hamilton, J. K.; Rebers, P. A. and Smith, F. (1956). Colorimetric method for determination of sugars and related substances. Analyt. Chem., 28: 350–356.
EL-Sheekh, M. M. and Mahmoud, YA-G. (2017). Technological approach of bioremediation using microbial tools: bacteria, fungi, and algae. In: Bhakta JN (ed) Handbook of research on inventive bioremediation techniques. IGI Global, USA, pp 134–154.
EL-Sheekh, M. M.; Farghl, A.; Gala, H. R. and Bayoumi, H. S. (2016). Bioremediation of different types of polluted water using microalgae. Rend. Fis. Acc. Lincei., 27(2):401–410.
Elumalai, S.; Saravanan, G. K.; Ramganesh, S.; Sakhtivel, R. and Prakasam, V. (2013).Phycoremediation of textile dye industrial effluent from tirupur district, Tamil Nadu, India. International Journal of Science Innovations and Discoveries, 3(1): 31-37.
Faafeng, B. A.; van Donk, E. and Källqvist, T. (1994). In situ measurement of algal growth potential in aquatic ecosystems by immobilized algae. J. Appl. Phycol., 6: 301–308.
Fedorova, G.; Golovko, O.; Randak, T. and Grabic, R. (2014). Storage effect on the analysis of pharmaceuticals and personal care products in wastewater. Chemosphere, 111:55–60.
Ho, SH.; Chen, CY. and Chang, JS. (2012). Effect of light intensity and nitrogen starvation on CO2 fixation and lipid/carbohydrate production of an indigenous microalga Scenedesmus obliquus CNW-N. Bioresour. Technol., 113: 244–252.
Jimenez-Perez, M. V.; Sanchez-Castillo, P.; Romera, O.; Fernandez-Moreno, D. and Perez- Martinez, C. (2004). Growth and nutrient removal in free and immobilized planktonic green algae isolated from pig manure. Enzyme Microb. Technol., 34: 392–398.
Kshirsagar, C. (2010). Ecofriendly and cost effective treatment of herbal and bulk drug pharmaceutical wastewaters using Spirulina, Indian J. Environmental Protection, 30: 773-779.
Kvarnryd, M.; Grabic, R.; Brandt, I. and Berg, C. (2011). Early life progestin exposure causes arrested oocyte development, oviductal agenesis and sterility in adult Xenopus tropicalis frogs. Aquat. Toxicol., 103: 18–24.
Larsdotter, K. (2006). Wastewater treatment with microalgae – a literature review. Vatten, 62:31–38.
Lau, P. S.; Tam, N. F. Y. and Wong, Y. S. (1995). Effect of algal density on nutrient removal from primary settled wastewater. Environ. Pollut., 89: 56–66.
Lau, P. S.; Tam, N. F. Y. and Wong, Y. S. (1997). Wastewater nutrients (N and P) removal by carrageenan and alginate immobilized Chlorella vulgaris. Environ. Technol., 18: 945–951.
Lee, J.; Lee, J.; Shukla, SK.; Park, J. and Lee, TK. (2016). Effect of algal inoculation on COD and nitrogen removal and indigenous bacterial dynamics in municipal wastewater. J. Microbiol. Biotechnol., 26:900–908.
Lessel, TH. (1994). Upgrading and nitrification by submerged bio-film reactors-experiences from a large scale plant. Water Sci. Technol., 29:167–174.
Li, H. j.; Wang, J. and Zhang, J. L. (1991). Removal of nutrient salts in relation with algae in ponds. Water Sci. and Tech., 24:5, 75-83.
Lowry, O. H.; Rosebrough, N. J.; Farr, A. L. and Randall, R. J. (1951). Protein measurement with the Folin phenol reagent. J. Biol. Chem., 193: 265–275.
Mahapatra, D. M.; Chanakya, H. N. and Ramachandra, T. V. (2013). Treatment efficacy of algae-based sewage treatment plants, Environ. Monit. and Assess., 185(9):7145–7164.
Malakootian, M.; Hatami, B.; Dowlatshahi, S. and Rajabizadeh, A. (2015). Optimization of culture media for lipid production by Nannochloropsis oculata for Biodiesel production. Environmental Health Engineering and Management Journal, 2(3):141–147.
Mallick, N. (2002). Biotechnological potential of immobilized algae for wastewater N, P and metal removal: a review. Biometals., 15:377–390.
Mandal, S. and Mallick, N. (2009). Microalga Scenedesmus obliquus as a potential source for biodiesel production. Appl. Microbiol. and Biotechnol., 84 (2):281–291.
Moreira, SM.; Moreira-Santos, M.; Guilhermino, L. and Ribeiro, R. (2006). Immobilization of the marine microalga Phaeodactylum tricornutum in alginate for in situ experiments: bead stability and suitability. Enzyme Microb. Technol., 38:135–141.
Ozkurt, I. (2009). Qualifying of safflower and algae for energy. Energy Educ. Sci. Tech., 23:145–51.
Promya, J.; Traichaiyaporn, S. and Deming, R. (2008). Phytoremediation of kitchen wastewater by Spirulina platensis (Nordstedt) Geiteler: pigment content, production variable cost and nutritional value. Maejo International Journal of Science and Technology, 2(1): 159-171.
Quek, E.; Ting, Y. P. and Tan, H. M. (2006). Rhodococcus sp. F92 immobilized on polyurethane foam shows ability to degrade various petroleum products. Bioresour. Technol., 97:32–38.
Rai, LC. and Mallick, N. (1992). Removal and assessment of toxicity of Cu and Fe to Anabaena doliolum and Chlorella vulgaris using free and immobilized cells. W. J. Microbiol. Biotechnol., 8: 110–4.
Ramola, B. and Singh, A. (2013). Heavy metal concentrations in pharmaceutical effluents of Industrial Area of Dehradun (Uttarakhand), India. Int. J. Environ. Sci. Res., 2(2):140–145.
Rana, R. S.; Singh, P.; Kandari, V.; Singh, R.; Dobhal, R. and Gupta, S. (2014). A review on characterization and bioremediation of pharmaceutical industries’ wastewater: an Indian perspective. Appl. Water Sci.,7:1–12.
Rao, P.; Kumar, R. R.; Raghavan, B. and Sivasubramanian, V. (2011). Application of phycoremediation technology in the treatment of wastewater from a leather-processing chemical manufacturing facility. – Water SA. 37(1): 7-14.
Revathi, S.; Kumar, S. M.; Santhanam, P.; Kumar, S. D.; Son, D. and Kim, M-K. (2017). Bioremoval of the indigo blue dye by immobilized microalga Chlorella vulgaris (PSBDU06). J. Sci. Ind. Res., 76(1):50–56.
Ricart, M.; Guasch, H.; Alberch, M.; Barcelo, D.; Bonnineau, C.; Geiszinger, A.; Farre, M.; Ferrer, J.; Ricciardi, F.; Romani, A. M.; Morin, S.; Proia, L.; Sala, L.; Sureda, D. and Sabater, S. (2010). Triclosan persistence through wastewater treatment plants and its potential toxic effects on river biofilms. Aquat. Toxicol., 100(4):346–353.
Rippka, R.; Deruelles, J.; Waterbery, J. B.; Herdman, M. and Stainer, R. Y. (1979). Generic assignments, strain histories and properties, pure cultures of cyanobacteria, J. Gen. Microbiol., 111: 1-61.
Robinson, P. K.; Mak, A. L. and Trevan, M. D. (1986). Immobilized algae: a review. Process Biochem., 21:122–126.
Ruiz-Marin, A.; Mendoza-Espinosa, L. G. and Stephenson, T. (2010). Growth and nutrient removal in free and immobilized green algae in batch and semi-continuous cultures treating real wastewater. Bioresour. Technol., 101:58–64.
Salama, A. M. and Shabana, E. F. (1989). The effects of nitrogen starvation, limitation, and recovery on the growth criteria and nitrogen metabolism of the cyanobacterium Phormidium fragile, Annals of Agric. Sc. Moshtohor, 27:559-571.
Sartory, D. P. and Grobbelaar, J. U. (1984). Extraction of chlorophyll a from freshwater phytoplankton for spectrophotometric analysis. Hydrobiologia, 114:177–187.
Shabana, E. F. (1994).Sewage treatment with microalgae. Sci. J. Fac. Sci. Menoufia Univ., 8: 29-45.
Singh, S. K.; Bansal, A.; Jha, M. K. and Dey, A. (2012). An integrated approach to remove Cr (VI) using immobilised Chlorella minutissima grown in nutrient rich sewage wastewater. Journal of Bioresource Technology, 104: 257-265.
Tam, N. F. Y. and Wong, Y. S. (1989). Wastewater nutrient removal byChlorella pyrenoidosa and Scenedesmus sp. Environ. Pollut., 58:19– 34.
Tam, N. F. Y. and Wong, Y. S. (1995).Wastewater treatment with microorganisms. The Bull. Fish. Res. Bd. Canada, 167-311.
Tam, N. F. Y. and Wong, Y. S. (2000). Effect of immobilized microalgal bead concentrations on wastewater nutrient removal. Environ. Pollut., 107:145-151.
UNESCO (2005). Water resources systems planning and management.
Vanerkar, A. P.; Satyanarayan, S. and Dharmadhikari, D. M. (2013). Full scale treatment of herbal pharmaceutical industry wastewater. Int. J. Chem. Phys. Sci., 2:52–62.
Vijayakumar, S. (2012). Potential Applications of Cyanobacteria in Industrial Effluents-A Review. J. Bioremed Biodeg., 3(154):1-4.
Vijayakumar, S. and Manoharan, C. (2012). Treatment of dye industry effluent using free and immobilized cyanobacteria. Bioremed. Biodeg., 3(165):1-6.
Voltolina, D.; Gomez-Villa, H. and Correa, G. (2005). Nitrogen removal and recycling by Scenedesmus obliquus in semicontinuous cultures using artificial wastewater and a simulated light and temperature cycle. Bioresource Technology, 96:359-362.
Vuppala, N. V. S.; Suneetha, C. and Saritha, V. (2012).Study on treatment process of effluent in bulk drug industry. Int. J. Res. Pharm Biomed. Sci., 3(3):1095–1102.
Wang, Y.; Tian, Y.; Han, B.; Zhao, HB.; Bi, JN. and Cai, BL. (2007) Biodegradation of phenol by free and immobilized Acinetobacter sp. strain PD12. J. Environ. Sci., 19:222–225.
Zhou, W. (2014).Potential Applications of Microalgae in Wastewater Treatments. In: Recent advances in microalgal biotechnology. OMICS Group ebook, Foster city, pp 1-9. | ||||
|
Statistics Article View: 363 PDF Download: 325 |
||||
