SENSORLESS VECTOR CONTROLLED THREE-PHASE PWM INVERTER-FED INDUCTION MOTOR DRIVE SYSTEM WITH AUTO-TUNING ESTIMATION OF MACHINE PARAMETER APPROACH | ||||
| Sohag Engineering Journal | ||||
| Article 4, Volume 1, Issue 1, March 2021, Page 34-48 PDF (777.26 K) | ||||
| Document Type: Original research articles | ||||
| DOI: 10.21608/sej.2021.155853 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
Khairy Sayed   ; Ahmed M. Kassem
| ||||
| Electrical Engineering Department, Sohag University, 82524, Sohag, Egypt | ||||
| Abstract | ||||
| This paper deal with a practical development technology on a highly accurate faster response adjustable speed drive implementation for the three-phase sinewave fed general purpose induction motor system which is based upon sensorless slip frequency type vector control scheme with an automatic auto-tuning machine parameter estimation strategy. The essential procedure and considerations to measure and estimate the exact stator and cage rotor circuit parameters of the induction motor treated here are discussed under its operating conditions. The speed regulation characteristics of the induction motor is illustrated and evaluated for the induction machine parameter variations under the actual operating conditions ranging from a low frequency to a high frequency for various specified load torque setting. The variable speed induction motor drive system employing sensorless slip frequency-based vector control scheme which incorporates the current controlled three-phase high frequency carrier PWM switching inverter with automatic auto-tuning estimation strategy on the temperature-dependent and -independent machine circuit parameters is practically implemented using DSP-based vector controller. The dynamic speed response performances under essentially changed load torque disturbances as well as steady state speed against torque characteristics of the proposed variable speed drive control and implementations are illustrated and discussed from an experimental point of view. | ||||
| Keywords | ||||
| Induction Motor Variable Speed Drive; Sensorless Slip Frequency-based Vector Control; Three-phase Sinewave PWM Inverter; Auto-Tuned Machine Parameters Estimation; High accurate quick response | ||||
| References | ||||
|
[1] Tung-Hai Chin, "Sensorless Vector Control for Induction motor," IEE Japan Trans. on IAS. Vol.112 pp.167-175, Mar. 1992. [2] K. Ohnishi, "Decoupling Control of Secondary Flux And Secondary Current In Induction Motor Drive With Controlled Voltage Source and Its Comparison With Volt/Herz Control"; Rec. of IEEE/IAS Annual Meeting Conf. Rec. pp. 678-685, Oct., 1982. [3] Tung-Hai Chin, “Hyperstability of the Full Order Adaptive Observer fir Vector Controlled-Induction Motor Drive without Speed-Sensor,” IEE Trans. on IAS. Vol.112. No.//pp.1047-1055, Nov. 1992 [4] T. Okuyama, “Vector Control Scheme of Induction Motor without Speed and Voltage Sensors,” IEE Japan Trans. on IAS. Vol.107. No.2 pp.191-198, Feb. 1987. [5] N. Yamamura, “PG-less Vector Control with Estimating Functions of Motor Parameter,” IEE Japan Trans. on IAS. Vol.107. No5. pp.373-378, May, 1991. [6] T. Okuyama, "Simplified Vector Control System without Speed and Voltage Sensors - Effect of Setting Errors in Control Parameters and their Compensation "; IEE Japan Trans. on IAS. Vol.110. pp.477-486, May, 1990 [7] Y. Okamura, "Speed Sensorless Control Scheme With Motor Parameter Identification Function for Vector Controlled Induction Motor Drives "; IEE Japan Technical Report of Rotation Machinery, RM-94-62, pp.21-30, Jun. 1994. [8] Y. Okamura, “High Performance Adjustable-Speed Induction Motor Drive System using Sensorless Vector Controlled PWM Inverter with Auto-Tuning Machine-Operated Parameter Estimation Schemes,” Powersystems World - Intelligent Motion System, pp.204-223, Sept. 1995. [9] Y. Okamura, “High Performance Adjustable-Speed Induction Motor Drive System using Sensorless Vector Control-based PWM Inverter with Auto-Tuning Machine-Operated Parameter Estimation Schemes”; Proc. of IEE-Korea International Conference on Power Electronics pp. 804-809, Oct. 1995. [10] R. Kassem, K. Sayed, A. Kassem, and R. Mostafa, “Power optimisation scheme of induction motor using FLC for electric vehicle,” IET Electrical Systems in Transportation, Vol. 10, No. 3, pp. 301-309, 2020.. [11] Ahmed G. Abo-Khalil, Ali M. Eltamaly, Mamdooh S. Alsaud, Khairy Sayed, Ali S. Alghamdi, “Sensorless control for PMSM using model reference adaptive system," International Transaction Electrical Energy System, Vol. 31, No. 2, 2021. [12] K. Sayed, A. Kassem, H. Saleeb, A. S. Alghamdi, A. G. Abo-Khalil, “Energy-Saving of Battery Electric Vehicle Powertrain and Efficiency Improvement during Different Standard Driving Cycles,” Sustainability. Vol. 12, No. 24, pp. 301-309, 2020. [13] Ali S. Alghamdi, Khairy Sayed, Ahmed G. Abokhalil, Ahmed Bilal Awan, Mohamed A. Zohdy, “A Soft Switching DC-Link Quasi Resonant Three-Phase Inverter for AC Servo-Motor Drive Applications,” International Transaction Journal of Engineering, Management, & Applied Sciences & Technologies, Vol. 12, No. 1, pp. 1-13, 2021. [14] A. M. Eltamaly, M. Al-Saud, K. Sayed, and A. G. Abo-Khalil, "Sensorless Active and Reactive Control for DFIG Wind Turbines Using Opposition-Based Learning Technique," Sustainability, Vol. 12, No. 9, p. 3583, 2020. [15] R. Kassem, K. Sayed, A. Kassem, R. Mostafa, "”Energy Efficient Control Scheme of Induction Motor Based EV,” 21st International Middle East Power Systems Conference (MEPCON), 2019. https://doi.org/10.1002/2050-7038.12733 [16] Liying Liu, Zhenlin Xu and Qiang Mei, “A sensorless vector control induction motor drive based on ADRC and flux observer,” 2009 Chinese Control and Decision Conference, Guilin, China, 2009, pp. 945-948, doi: 10.1109/CCDC.2009.5191888. [17] J. Titus, P. Harikrishnan and K. Hatua, "Sensorless Vector Control for a Load Commutated Inverter fed Active-Reactive Induction Motor Drive," 2019 IEEE 13th International Conference on Compatibility, Power Electronics and Power Engineering (CPE-POWERENG), Sonderborg, Denmark, 2019, pp. 1-6, doi: 10.1109/CPE.2019.8862386. [18] A. Iqbal and M. R. Khan, "Sensorless control of a vector controlled three-phase induction motor drive using artificial neural network," 2010 Joint International Conference on Power Electronics, Drives and Energy Systems & 2010 Power India, New Delhi, India, 2010, pp. 1-5, doi: 10.1109/PEDES.2010.5712474. [19] J.Mohanalakshmi and H. N. Suresh, “Sensorless speed estimation and vector control of an Induction Motor drive using model reference adaptive control,” 2015 International Conference on Power and Advanced Control Engineering (ICPACE), Bengaluru, India, 2015, pp. 377-382, doi: 10.1109/ICPACE.2015.7274976. [20] B. Renukrishna and S. S. Beevi, "Sensorless vector control of induction motor drives using rotor flux observer," 2012 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Bengaluru, India, 2012, pp. 1-5, doi: 10.1109/PEDES.2012.6484463. | ||||
|
Statistics Article View: 284 PDF Download: 261 |
||||
