MODIFICATION OF LOW DENSITY POLYETHYLENE BY RADIATION-INDUCED GRAFTING I. GRAFTING PROCEDURE, CHEMICAL MODIFICATION OF GRAFTED FILMS AND ELECTRICAL PROPERTIES | ||||
| Journal of the Egyptian Society of Engineers | ||||
| Article 8, Volume 50, Issue 4, August 2011, Page 26-20 PDF (615.04 K) | ||||
| Document Type: Scientific and technological | ||||
 View on SCiNiTO | ||||
| Author | ||||
| M. Madani M.* | ||||
| National Center for Radiation Research and Technology, Nasr City, Cairo, Egypt | ||||
| Abstract | ||||
| Radiation grafting of monomers onto suitable trunk polymers is a useful tool for tailoring new polymers for special purposes. The introduction of new characteristics to some synthetic polymers was achieved through the γ-radiation-induced graft copolymerization of methyl methacrylate onto low density polyethylene films (in the presence of aniline as inhibitor) for the preparation of grafted films. The influence of the reaction conditions on the grafting yield, such as the irradiation dose and the inhibitor was investigated. An alkaline treatment was carried out for the prepared graft copolymer to improve its ion-exchange property. The grafted and treated membranes were characterized to determine the structural changes with Fourier transform infrared spectroscopy. The electrical properties of the graft copolymer were studied. Improvements in the electrical conductivity with grafting were observed. The KOH treated films possessed higher electrical conductivity than the untreated ones. | ||||
| References | ||||
|
1- A. Bhattacharya, Prog. Polym. Sci. 25 (2000) 371.
2- B. Ramby, J.F. Rabek, (Eds.): Photodegradation, Photo-oxidation and Photostabilization of Polymers, Wiley, New York, 1975.
3- N.S. Allen, (Ed.): Degradation and Stabilization of Polyolefins, Applied Science Publishers, London, 1983.
4- J. A. Kuckzkowsky and J.G. Gillick, Rubber Chem. Technol., 57(1984) 621.
5- N. Grassie, G. Scott, Polymer Degradation and Stabilization, Cambridge University Press, London, 1985.
6- G. Scott, (Ed.): Developments in Polymer Stabilization - 8, Elsevier Applied Science Publishers, London, 1987.
7- L. Wojna´rovits, Radiation chemistry. In: A. Ve´rtes, S. Nagy and Z. Klencsar, (Eds.), Hand book of Nuclear Chemistry, Kluwer Academic Publishers, Dordrecht-Holand, 2003.
8- I. Kaur, R. Barsola, A. Gupta and B.N. Misra, J. Appl. Polym. Sci., 54 (1994) 1131.
9- E. Moura, E.S.R. Somessari, C.G. Silveira, H.A. Paes, C.A. Souza, W. Fernandes, J.E. Manzoli and A.B.C. Geraldo, Radiation Phys. Chem., 80 (2011) 175.
10- M. Madani, Current Appl. Phys., 11 (2011) 70.
11- K. Kato, E. Uchida, E.T. Kang, Y. Uyama and Y., Ikada, Prog. Polym. Sci., 28 (2003) 209.
12- M. Madani, S.S. Aly and S.M. El-Sayed, High Performance Polymers, 22 (2010) 515.
13- El-Sayed A. Hegazy, H. Kamal, M. Abdel Geleel and A. Abdel Maksoud, J. Appl. Polym. Sci.,95 (2005) 936.
14- S. Kiatkamjornwong, J. Chvajarenpun and C. Nakason, Radiat. Phys. Chem., 42 (1993) 50.
15- E. Bucio and G. Burillo, Radiat. Phys. Chem., 48 (1996) 805.
16- I. Kaur, B.N. Misra and S. Kumar, J. Appl. Polym. Sci., 69 (1998) 143.
17- M. T. Razzak and K. Otsuhata, J. Appl. Polym. Sci., 36 (1998) 645.
18- K. Kaji, M. Hatada, I. Yoshizawa, C. Kohara and K. Komai, J. Appl. Polym. Sci., 37 (1989) 2153.
19- S. H. Choi, Y.C. Nho and G.T. Kim, J. Appl. Polym. Sci. 71 (1999) 643.
20- A. Charlesby, Atomic Radiation and Polymers, Pergamon, Press New York (1960).
21- A. R. Blythe, "Electrical Properties of Polymers", Cambridge University Press, London, New York, Melbourne, (1979). | ||||
|
Statistics Article View: 33 PDF Download: 27 |
||||
