BIOGAS UTILIZATION FOR POWERING WATER IRRIGATION PUMP | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 71, Volume 25, Issue 4, October 2008, Page 1438-1453 PDF (348.23 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2008.190278 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| Ashrf Abdel-Galil; Mubarak M. Mostafa; Mahmoud A. Elnono; Mostafa F. Mohamed | ||||
| Agric. Eng. Dept., Fac. Of Agric., Ain Shams Univ., Egypt. | ||||
| Abstract | ||||
| A simple method and technique for handling, storing and utilizing of biogas have been done. SI engine was modified to power a water pump for irrigation by using 100% biogas as fuel (gasoline starting). A gas mixing device was designed to meter biogas into air stream of amount dictated by the engine speed and the load to obtain a proper proportion of biogas and air that burn for SI engine operation. An inner tube of tractor tire was used for storing and handling biogas from the biogas digester to the engine-pump site. It was filled up with biogas by using a modified passenger car compressor. Biogas was analyzed to determine CO2 percentage by using alkaline Ca(OH)2. The average percentage of CH4 and CO2 were found to be approximately 69.6% and 30.4%, respectively. The calorific value of biogas was calculated and found to be 29360.7 kJ/ m3. A comparison between biogas and the liquid fuel (kerosene and gasoline) was made. The results showed that at 2500 rpm engine speed, specific energy consumption under biogas mode was decreased by an average of 80.3% and 79% when compared to gasoline and kerosene mode of operation, respectively. The total pump efficiency of biogas operation was about 58%. | ||||
| Keywords | ||||
| bio-fuels; biogas; gasoline engine; engine performance, pump performance | ||||
| References | ||||
|
Alaa EL-Din, M. N.; S. A. EL-Shimi; M. H. Mahmoud and A. M. Abdel Aziz (1983). Biogas for Egyptian villages (Energy – Fertilizer – Forage). Soil and Water Research Institute, Agric. Res. Centre.
ASAE standards (1997). (44th Ed.). The Amirican Society of Agricultural Engineers (ASAE). Miami. USA.
House, D. (1981). Biogas Handbook. peace press, Inc Culver City, California 90230 USA.
El-Gindy, A.; M. El-Nono; A. Hamam and M. Hisham (2002). Devlopment of axial-flow pump for surface irrigation systems Misr J. Ag. Eng. 19 (2): 478-490
HDR Engineering inc. staff (2002). Handbook of public water systems. Jhon Wiley and sons
Helmy, M.A.; A.A. Abd El-Rhman; M.T. Ebid; and M.A. Hassan (2003). Expectant production of biogas and fertilizer from different residues fermentation using biogas unit. Misr J.Ag.Eng., 20 (4): 949-964
ISAT Information and Advisory Service on Appropriate Technology (1991). Biogas Digest. a publication of Deutsches Zentrum fur Entwicklung stecknologien, GATE.
Jewell, W. J. (1986). cogeneration of Electricity and Heat from biogas, Report for Science and Education Administration., U.S.Dept. of Energy, Solar Energy Research Institute, NY State College of Agriculture and Life Sciences.
Kofoed, E. and B. Hansen (1981). Gas Motors In Northeast Regional. Agricultural Engineering Service, Ithaca, NY.
Lettinaga, G. and A.Van Haandel (1992). Renewable energy, sources for fuels and electricity" Covelo, CA: Island press. Ch. 19 P: 817-839
Porpatham, E.; A. Ramesh and N. Nagalingam (2007). Effect of hydrogen addition on the performance of biogas fuelled spark ignition engine. International journal of Hydrogen energy Vol. (32) p: 2057- 2065
Robert, L. S.; T. George; E. Bayard and M. Garr (1998). Pumping station design. Butterworth Heinemann, second edition p: 423- 430.
Von Mitzlaff (1988). Engines for biogas. a publication of Deutsches Zentrum fur Entwicklung stecknologien, GATE.
Walsh, J.L. ; C.C. Ross; M. S. Smith; S. R. Harper and W.A. Wilkins (1988). Handbook on biogas utilization. the Environment, ,Health, and Safety Division Georgia Tech Research Institute Atlanta. Georgia
White, F.M. (1979). Fluid mechanics McGraw-Hill, Inc. New York. USA, p: 320-322 | ||||
|
Statistics Article View: 315 PDF Download: 178 |
||||
