DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS
EI-SAHRIGI, A., ABDEL LATIF, S., EL-BAKHSHWAN, M. (2007). DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS. EKB Journal Management System, 85(1), 263-279. doi: 10.21608/ejar.2007.213653
AHMED F. EI-SAHRIGI; SALAH M. ABDEL LATIF; MOSTAFA K. EL-BAKHSHWAN. "DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS". EKB Journal Management System, 85, 1, 2007, 263-279. doi: 10.21608/ejar.2007.213653
EI-SAHRIGI, A., ABDEL LATIF, S., EL-BAKHSHWAN, M. (2007). 'DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS', EKB Journal Management System, 85(1), pp. 263-279. doi: 10.21608/ejar.2007.213653
EI-SAHRIGI, A., ABDEL LATIF, S., EL-BAKHSHWAN, M. DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS. EKB Journal Management System, 2007; 85(1): 263-279. doi: 10.21608/ejar.2007.213653

DEVELOPMENT AND IMPROVMENT OF KEROSENE ENGINE TO OPERATE ON BIOGAS

Egyptian Journal of Agricultural Research
Article 22, Volume 85, Issue 1, March 2007, Page 263-279  XML PDF (3.51 MB)
Document Type: Original Article
DOI: 10.21608/ejar.2007.213653
View on SCiNiTO View on SCiNiTO
Authors
AHMED F. EI-SAHRIGI1; SALAH M. ABDEL LATIF2; MOSTAFA K. EL-BAKHSHWAN3
1Professor of Agricultural Engineering, Faculty of Agriculture, Ain Shams University, Cairo, Egypt
2Professor of Agricultural Engineering, Faculty of Agriculture, Mansoura University, Mansoura, Egypt
3General manger, Agricultural Engineering Research Institute, Agricultural Research Center, Dokki, Giza, Egypt
Abstract
This research work was carried out in the biogas laboratory of the Agricultural Engineering Department, Faculty of Agriculture, Mansoura University. The main objectives were to utilize biogas as a fuel for operating a modified kerosene engine that was used to drive an electric generator. The modification constituted the design of a mixing chamber connected to the intake manifold of the engine. The performance and efficiency of the engine were studied under all possible operating conditions using togas fuel with six different nozzle diameters (4, 5, 6, 7, 8, and 9 mm) and generator electric loads (0, 0.29, 0.58, 0.87, 1.16, 1.43, and 1.62 kW). It was compared with an engine operating on kerosene fuel only. The obtained results showed that the biogas can be used as a new fuel for operating the modified engine-generator unit at the rated and maximum output of generator (1.43 and 1.62 kW, respectively) using nozzle diameter of 5 mm under biogas pressure ranging from 19 to 21 mbar. Under these conditions, high brake thermal efficiency and mechanical efficiency of the engine and high generator thermal efficiency and electric generation efficiency were 28.03, 80.33 and 81.93%, respectively. The obtained data also revealed that, using nozzle diameter of 5 mm, resulted in reduction in the biogas consumption and specific biogas consumption rate.
Statistics
Article View: 57
PDF Download: 174