Viscosity and Total Organic Carbon Removal in High-Solid Anaerobic Digestion of Sewage Sludge | ||||
Engineering Research Journal (Shoubra) | ||||
Volume 51, Issue 3, July 2022, Page 60-66 PDF (912.9 K) | ||||
Document Type: Research articles | ||||
DOI: 10.21608/erjsh.2022.249387 | ||||
View on SCiNiTO | ||||
Authors | ||||
Ahmed M. Aboulfotoh1; Hanan A. Fouad2; Ahmed Y. Bakry3; Rehab El-hefny4 | ||||
1Associated Professor, Environmental Engineering Department, Faculty of Engineering, Zagazig University. | ||||
2Professor, Environmental Engineering Department, Faculty of Engineering at Shubra, Benha University, Egypt. | ||||
3Assistant Lecturer, Environmental Engineering Department, Faculty of Engineering at Shubra, Benha University, Egypt. | ||||
4Associated Professor, Environmental Engineering Department, Faculty of Engineering at Shubra, Benha University, Egypt. | ||||
Abstract | ||||
A batch test was done to study the effect of anaerobic mono-digestion of sludge and pretreatment on the sludge properties like viscosity and total organic carbon removal. After the Biome thane potential test of the first and second sets ended, samples of an aerobically digested sludge were analyzed for TOC removal. Set one and set two ended after 22 days. Set 1 shows that the best TOC removal was caused for the concentration of 11% for the pretreated and blank reactors and it was 33.92% and 27.25% respectively. The minimum removal ratio occurred at 16% concentration for the pretreated and blank reactors. Set 2 shows that the best TOC removal was caused for the reactor at a pre-treatment temperature of 180℃ and it was 35.83% and which was higher than the removal of the blank reactor which was 27.50%. The maximum biogas produced was 2475 ml at 11% TS with an improvement of 55.56% and in terms of TOC removed, it was 189.19 mLbiogas/gTOCremoved. In set 2, The maximum Biogas produced was 3645 ml at 11% TS with an improvement of 60.57% and pretreatment temperature of 180℃ and in terms of TOC removed, it was 169.53 mLbiogas/gTOCremoved. Sludge viscosity is enhanced after thermal pretreatment and improved the mixing of the high solid sludge | ||||
Keywords | ||||
Digestion; Anaerobic digestion; Sewage sludge, viscosity, Total Organic Carbon | ||||
Statistics Article View: 103 PDF Download: 178 |
||||