SIMULATION OF DESALINATION OF SALT WATER COMPRISING POLYPROPYLENE HOLLOW FIBRE MEMBRANES | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 3, Volume 40, Issue 2, April 2023, Page 139-160 PDF (1.95 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2023.188580.1095 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
Mahmoud M. Elewa1; Omar Ramadan2; Mahmoud ْ A. El-Emam3; Abdelaziz I. Omara  4
| ||||
| 1Assoc. Prof. of Environ. Eng., Arab Academy for Science and Technology and Maritime Transport, Alexandria, Egypt. | ||||
| 2Assist. Prof. of Environ. Eng., Dept. of Architecture and Built Environ., U. of Nottingham, UK. | ||||
| 3Assist. Prof of Ag. Power and Mach. Eng., Ag. and Biosystems Eng. Dept., Fac. of Ag., Alexandria U., Egypt. | ||||
| 4Assoc. Prof. of Ag. Irrigation and Drainage Eng., Ag. and Biosystems Eng. Dept., Fac. of Ag., Alexandria U., Egypt. | ||||
| Abstract | ||||
| The problem of desalination systems using advanced hollow fibre (HF) membranes were thoroughly investigated. Humidification air is cooled by heat transfer in the dehumidification chamber, which condenses the water vapour and produces high-quality, fresh drinking water. A mathematical approach was conducted, and a simulation programme (model) was developed for the system. The performance of the HF membranes was assessed using different mass flows of salt water and air to optimise the system's operating performance. An experimental setup was prepared to test the effect of changing the operating parameters on the produced fresh water's flux. The produced flux ranged from 2.36–10.6 kg h-1 m-2 at 40–70oC, respectively. The comparisons between the simulation results and the experimental setup were in good agreement, and the water quality analysis showed that the obtained values were within the World Health Organization's drinking water guidelines. | ||||
| Keywords | ||||
| Desalination; Humidification- Dehumidification; Hollow-fibre Membranes; Mathematical Model | ||||
| References | ||||
|
Al-Otoom A. and Al-Khalaileh A.T. (2020) Water desalination using solar continuous humidification–dehumidification process using hygroscopic solutions and rotating belt. Solar Energy 197:38-49.
Arnot T. and Mattia D. (2011) A review of reverse osmosis membrane materials for desalination–development to date and future potential. Journal of Membrane Science.
Ayati E., Rahimi-Ahar Z., Hatamipour M.S. and Ghalavand Y. (2019) Water productivity enhancement in variable pressure humidification dehumidification (HDH) desalination systems using heat pump. Applied thermal engineering 160:114114.
Becker S. (2014) Foundations of heat transfer. von FP incropera, DP dewitt, TL bergman, AS lavine. Chemie Ingenieur Technik 3:395-396.
Bennett C. (1952) Absorption and Extraction. Thomas K. Sherwood and Robert L. Pigford. New York-London: McGraw-Hill, 1952. 478 pp. $7.50. Science 116:156-156.
Chen Q., Burhan M., Shahzad M.W., Ybyraiymkul D., Akhtar F.H. and Ng K.C. (2020) Simultaneous production of cooling and freshwater by an integrated indirect evaporative cooling and humidification-dehumidification desalination cycle. Energy conversion and management 221:113169.
Datta A.K. (2007) Porous media approaches to studying simultaneous heat and mass transfer in food processes. I: Problem formulations. Journal of Food Engineering 80:80-95.
El‐Dessouky H., Shaban H.I. and Al‐Ramadan H. (1996) Multi‐stage flash desalination process: A thermal analysis. Developments in Chemical Engineering and Mineral Processing 4:5-22.
Elbassoussi M.H., Mohammed R.H. and Zubair S.M. (2020) Thermoeconomic assessment of an adsorption cooling/desalination cycle coupled with a water-heated humidification-dehumidification desalination unit. Energy conversion and management 223:113270.
Elzayed M.S., Ahmed M., Qasem N.A., Antar M.A. and Zubair S.M. (2020) A design procedure to size thermodynamically-balanced humidification-dehumidification desalination systems. Energy conversion and management 224:113357.
Faegh M. and Shafii M.B. (2020) Thermal performance assessment of an evaporative condenser-based combined heat pump and humidification-dehumidification desalination system. Desalination 496:114733.
Gabelich C.J., Williams M.D., Rahardianto A., Franklin J.C. and Cohen Y. (2007) High-recovery reverse osmosis desalination using intermediate chemical demineralization. Journal of Membrane Science 301:131-141.
He W., Chen J., Han D., Luo L., Wang X., Zhang Q. and Yao S. (2019a) Energetic, entropic and economic analysis of an open-air, open-water humidification dehumidification desalination system with a packing bed dehumidifier. Energy conversion and management 199:112016.
He W., Han D., Zhu W. and Ji C. (2018) Thermo-economic analysis of a water-heated humidification-dehumidification desalination system with waste heat recovery. Energy conversion and management 160:182-190.
He W., Yang H. and Han D. (2019b) Thermodynamic investigation and optimization of a heat pump coupled open-air, open-water humidification dehumidification desalination system with a direct contact dehumidifier. Desalination 469:114101.
Jabari F., Nazari-heris M., Mohammadi-ivatloo B., Asadi S. and Abapour M. (2020) A solar dish Stirling engine combined humidification-dehumidification desalination cycle for cleaner production of cool, pure water, and power in hot and humid regions. Sustainable Energy Technologies and Assessments 37:100642.
Lawal D.U., Antar M.A., Khalifa A., Zubair S.M. and Al-Sulaiman F. (2020) Experımental investigation of heat pump driven humidification-dehumidification desalination system for water desalination and space conditioning. Desalination 475:114199.
Lawson K.W. and Lloyd D.R. (1996) Membrane distillation. I. Module design and performance evaluation using vacuum membrane distillation. Journal of Membrane Science 120:111-121.
Lawson, K. W., & Lloyd, D. R. (1996). Membrane distillation. II. Direct contact MD. Journal of Membrane Science, 120(1), 123–133. https://doi.org/10.1016/0376-7388(96)00141-X
Li G.-P., Qi R.-h. and Zhang L.-Z. (2019) Performance study of a solar-assisted hollow-fibre-membrane-based air humidification-dehumidification desalination system: Effects of membrane properties. Chemical Engineering Science 206:164-179.
Martínez-Díez, L., & Vázquez-González, M. I. (1999). Temperature and concentration polarization in membrane distillation of aqueous salt solutions. Journal of Membrane Science, 156(2), 265–273. https://doi.org/10.1016/S0376-7388(98)00349-4
Mohamed A., Ahmed M.S. and Shahdy A.G. (2020) Theoretical and experimental study of a seawater desalination system based on humidification-dehumidification technique. Renewable Energy 152:823-834.
Nada S., Elattar H. and Fouda A. (2015) Experimental study for hybrid humidification–dehumidification water desalination and air conditioning system. Desalination 363:112-125.
Pourafshar S.T., Jafarinaemi K. and Mortezapour H. (2020) Development of a photovoltaic-thermal solar humidifier for the humidification-dehumidification desalination system coupled with heat pump. Solar Energy 205:51-61.
Qasem N.A. and Zubair S.M. (2019) Performance evaluation of a novel hybrid humidification-dehumidification (air-heated) system with an adsorption desalination system. Desalination 461:37-54.
Rahimi-Ahar Z., Hatamipour M.S., Ghalavand Y. and Palizvan A. (2020) Comprehensive study on vacuum humidification-dehumidification (VHDH) desalination. Applied thermal engineering 169:114944.
Sachdev T., Gaba V.K. and Tiwari A.K. (2020) Performance analysis of desalination system working on humidification-dehumidification coupled with solar assisted air heater and wind tower: Closed and open water cycle. Solar Energy 205:254-262.
Sayyaadi H. and Saffari A. (2010) Thermoeconomic optimization of multi effect distillation desalination systems. Applied Energy 87:1122-1133.
Sharshir S., Peng G., Yang N., Eltawil M.A., Ali M.K.A. and Kabeel A. (2016) A hybrid desalination system using humidification-dehumidification and solar stills integrated with evacuated solar water heater. Energy conversion and management 124:287-296.
Shatat M., Omer S., Gillott M. and Riffat S. (2013) Theoretical simulation of small scale psychometric solar water desalination system in semi-arid region. Applied thermal engineering 59:232-242.
Shehata A.I., Kabeel A., Dawood M.M.K., Elazm M.M.A., Abdalla A.M. and Mehanna A. (2019) Achievement of humidification and dehumidification desalination system by utilizing a hot water sprayer and ultrasound waves techniques. Energy conversion and management 201:112142.
Teow Y.H. and Mohammad A.W. (2019) New generation nanomaterials for water desalination: A review. Desalination 451:2-17.
Wang N., Wang D., Dong J., Wang H., Wang R., Shao L. and Zhu Y. (2020) Performance assessment of PCM-based solar energy assisted desiccant air conditioning system combined with a humidification-dehumidification desalination unit. Desalination 496:114705.
Wang Z., Dou B., Zheng L., Zhang G., Liu Z. and Hao Z. (2012) Effective desalination by capacitive deionization with functional graphene nanocomposite as novel electrode material. Desalination 299:96-102.
Welgemoed T.J. (2006) Capacitive deionization technologyTM development and evaluation of an industrial prototype system, University of Pretoria.
Yang C.-M., Choi W.-H., Na B.-K., Cho B.W. and Cho W.I. (2005) Capacitive deionization of NaCl solution with carbon aerogel-silicagel composite electrodes. Desalination 174:125-133.
Zhang L.-Z. (2011) An analytical solution to heat and mass transfer in hollow fibre membrane contactors for liquid desiccant air dehumidification. Journal of heat transfer 133.
Zhang L.-Z. and Huang S.-M. (2011) Coupled heat and mass transfer in a counter flow hollow fibre membrane module for air humidification. International Journal of Heat and Mass Transfer 54:1055-1063.
Zhang L.-Z. and Li G.-P. (2017) Energy and economic analysis of a hollow fibre membrane-based desalination system driven by solar energy. Desalination 404:200-214. | ||||
|
Statistics Article View: 348 PDF Download: 173 |
||||
