ENHANCEMENT OF POULTRY WASTE COMPOST BY ADDING BIOCHAR | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 10, Volume 40, Issue 4, October 2023, Page 419-434 PDF (1.46 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2023.222627.1108 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
M. A. Rashwan1; M. S. Al-harby2; A. I. Omara  3; M. I. Morsy3
| ||||
| 1Prof., Dept. of Ag. & Biosystems Eng., Fac. of Ag., Alex. U., Alex., Egypt. Currently at Ag. Eng. Dept., Collage of Food & Ag. Sciences, King Saud U., Saudi Arabia. | ||||
| 2Eng., Dept. of Ag. Eng., Collage of Food & Ag. Sciences, King Saud U., Saudi Arabia. | ||||
| 3Assoc. Prof., Dept. of Ag. & Biosystems Eng., Fac. of Ag., Alex. U., Alex., Egypt. | ||||
| Abstract | ||||
| The process of converting poultry waste into organic fertilizer is the best option, but the challenge in treating nitrogenous waste is the easy loss of nitrogen and the increase in methane emissions. Thus, the aim of this study was to determine the best mixing ratio of biochar )BC( for the production of organic fertilizer and to test the degree of maturity and stability of the produced fertilizer through maturity and stability tests. Addition of BC to the poultry litter (PL) was very beneficial, as it gave several initial indications of the possibility of producing good organic fertilizer. BC was added to the PL in proportions of 0%, 5%, 10%, and 20% by weight to produce compost using cylindrical bioreactors. The results showed that the addition of 10-20% of biochar to poultry litter achieved the highest average temperature (62.2, and 67.5 °C, respectively) after 48 hours from the start of operation. The decrease of percentage of organic matter, volatile solids, and ash during the the active stage are indicators of increased microbial activity and analysis of organic matter. The maturity and stability tests (Solvita index and Dewar’s test) as well as the phytotoxicity test (germination index) proved that the compost contains 10-20% biochar, is mature, and stable compost with low ammonia. Therefore, adding biochar to the poultry litter leads to improve the homogeneity and building the mixture and stimulating the microbial activity in the compost mixture, and this has good economic effects in terms of accelerating the process of compost production. | ||||
| Keywords | ||||
| Composting; poultry litter; biochar; maturity and stability; germination index | ||||
| References | ||||
|
Abdul Kadir, A., S. N. Jamaludin, and N.W. Azhar, (2016) An overview of composting based on variable feedstock material. MATEC Web Conf., 47, 05016.
Adel, R. A., A. Usman, M. Abduljabbar, Y. Vithanage, S. Ok, M. Ahmad, J. Elfaki, S. S. Abdulazeem, and M. I. Al-Wabel. (2015) Biochar production from date palm waste: Charring temperature induced changes in composition and surface chemistry. Retrieved from Science Direct at the follwing address: https://wwwsciencedirectcom.sdl.idm.oclc.org/science/article/pii/S0165237015301492.
Alkoaik, F., A. Al-Faraj, I. Al-Helal, R. Fulleros, M. Ibrahim, and A. Abdel-Ghany, (2020) Toward Sustainability in Rural Areas: Composting Palm Tree Residues in Rotating Bioreactors. Sustainability, 2020, 12, 201; doi:10.3390/su12010201
Al-Wabel, M.I., A. R A. Usman, A. S. Al-Farraj, Y. OK, A. Abduljabaar, A. Al-Faraj, and A. Sallam, (2019) Date palm waste biochars alter a soil respiration, microbial biomass carbon, and heavy metal mobility in contaminated mined soil. Environ Geochem Health 41:1705–1722. https://doi.org/10.1007/s10653-017-9955-0
Asgharipour, M., and A. Sirousmehr, (2012) Comparison of three techniques for estimating phytotoxicity in municipal solid waste compost. Annu. Biol. Res. 3 (2):1094–101.
ASTM International Standard, (2016) Available online: https://www.techknowledge.me/files/theme/KC/ASTM/astm_standards2016.pdf
Atkinson, C. J., J. D. Fitzgerald, and N. A. Hipps, (2010) Potential mechanisms for achieving agricultural benefits from biochar application to temperate soils: a review. Plant Soil, 337:1–18
Barral, M., and R. Paradelo, (2011) A review on the use of phytotoxicity as a compost quality indicator. Dyn. Soil Dyn. Plant 5 (2):36–44.
Bazrafshan, E., A. Zarei, K. Mostafapour, N. Poormollae, S. Mahmoodi, and M. Zazouli, (2016) Maturity and stability evaluation of composted municipal solid wastes. Health Scope 5 (1):1–9.
Beesley, L., E. Moreno-Jime´nez, J. L. Gomez-Eyles, (2010) Effects of biochar and green waste compost amendments on mobility, bioavailability and toxicity of inorganic and organic contaminants in a multi-element polluted soil. Environ Pollut., 158:2282–7.
Biddlestone, A. J. and K. R. Gray, (1985) Composting In: Robinson C.W. and Howell, J.A. (eds.). Comperhensive Biotechnology, Pergamon Press, Oxford & New York. vol. 4, pp. 1059-1070. doi:10.1080/01904167.2018.1554682.
Buchanan, M., W. Brinton, F. Shields, J. West, and W. Thompson, (2001) California compost maturity index. Manuscript report to CIWMB https://woodsend.com/wpcontent/uploads/2019/09/Compost-Maturity-Index_
Bustamante, M., C. Paredes, F. Marhuenda-Egea, A. Espinosa, M. Bernal, and R. Moral, (2008) Co-composting of distillery wastes with animal manures: Carbon and nitrogen transformations in the evaluation of compost stability. Chemosphere 72:551–57.
Butler, T. A., L. J. Sikora, P. M. Steinhilber, and L. W. Douglass, (2001) Compost age and sample storage effects on maturity indicators of biosolids compost. J. Environ. Qual. 30, 2141–2148.
Deenik, J. L., A. Diarra, G. Uehara, S. Campbell, Y. Sumiyoshi, and M. J. Antal, (2011) Charcoal Ash and Volatile Matter Effects on Soil Properties and Plant Growth in an Acid Ultisol. Soil Sci., 176:336–345.
Domingues, R. R., P. F. Trugilho, C. A. Silva, I. C. N. deMelo, L. C. Melo, Z. M., Magriotis, and M. A. Sanchez-Monedero, (2017) Properties of biochar derived from wood and high-nutrient biomasses with the aim of agronomic and environmental benefits. PloS One, 12(5), e0176884.
Elcik, H., A. Zoungrana, and N. Bekaraki, (2016) Laboratory-scale investigation of aerobic compost ability of municipal solid waste in Istanbul. Sigma J. Eng. & Nat. Sci. 34 (2):211–20.
Ells, J., A. McSay, and S. M. Workman (1991) Toxic effects of manure, alfalfa and ammonia on emergence and growth of cucumber seedlings. Hortic. Sci. 26:380–83.
Estevez-Schwarz, I., S. Seoana-Labandeira, A. Nunez-Delgado, and E. Lopez-Mosquera, (2012) Production and characterization of compost made from garden and other waste. Pol. J. Environ. Stud. 21 (4):855–64.
Faiad, A., Muath Alsmari, Mohamed M. Z. Ahmed, Mohamed L. Bouazizi, Bandar Alzahrani and Hussien Alrobei (2022). Date Palm Tree Waste Recycling: Treatment and Processing for Potential Engineering Applications. Sustainability 2022, 14, 1134. https://doi.org/10.3390/su14031134
FAO, (2023) Food and Agriculture Organization of the United Nations. Date palm in the Arab region. https://www.fao.org/3/cb9917en/cb9917en.pdf
Francioli, D., E. Schulz, G. Lentendu, T. Wubet, F. Buscot, and T. Reitz, (2016) Mineral vs. Organic Amendments: Microbial Community Structure, Activity and Abundance of Agriculturally Relevant Microbes Are Driven by Long-Term Fertilization Strategies. Front. Microbiol. 7, 1446.
Ganguly, R. K., and S. K. Chakraborty, (2018) Assessment of microbial roles in the bioconversion of paper mill sludge through vermicomposting. J. Environ. Health Sci. Eng., 16, 205–212.
Gao, M., F. Liang, B. Yub, and L. Yang, (2010) Evaluation of stability and maturity during forced-aeration composting of chicken manure and sawdust at different C/N ratios. Chemosphere 78:614–19.
Glaser, B., and J. J. Birk, (2012) State of the scientific knowledge on properties and genesis of anthropogenic dark earths in Central Amazonia (terra preta de Índio). Geochim Cosmochim Acta, 82:39–51. doi:10.1016/ j.gca.2010.11.029
Glaser, B., J. Lehmann, W. Zech, B. Glaser, J. Lehmann, and W. Zech, (2002) Ameliorating physical and chemical properties of highly weathered soils in the tropics with charcoal-a review. Biol Fertil Soils, 35: 219–230. doi:10.1007/s00374-002-0466-4
Guo, R., G. Li, T. Jiang, F. Schuchardt, T. Chen, Y. Zhao, and Y. Shen, (2012) Effect of aeration rate, C/N ratio and moisture content on the stability and maturity of compost. Bioresource Technology, 112, 171-178. https://doi.org/10.1016/j.biortech.2012.02.099
Haug, R., (1993) The practical handbook of compost engineering, 377–78. Boca Raton, Florida: Lewis publishers.
Iqbal, M. K., A. Nadeem, F. Sherazi, R. A. Khan, (2015) Optimization of process parameters for kitchen waste composting by response surface methodology. International Journal of Environmental Science and Technology, 12, 1759-1768.
Jimenez, E. I., and V. P. Garcia, (1989) Evaluation of city refuse compost maturity. A review. Biological Wastes. 27: 55-142.
Kumar, A., E. Singh, L. Singh, S. Kumar, and R., Kumar, (2021) Carbon material as a sustainable alternative towards boosting properties of urban soil and foster plant growth. Sci. Total Environ. 751, 141659.
Lehmann, J. and S. Joseph, (2015) Biochar for Environmental Management: Science, Technology and Implementation. Second ed. Routiedge, London.
Lehmann, J., and S. Joseph, (2009) Biochar for Environmental Management: Science and Technology. London; Sterling, VA: Earthscan.
Lehmann, J., J. P. da Silva, C. Steiner, T. Nehls, W. Zech, and B. Glaser, (2003) Nutrient availability and leaching in an archaeological Anthrosol and a Ferralsol of the central amazon basin: fertilizer, manure and charcoal amendments. Plant Soil, 249, 343-357.
Manohara, B., and S. Belagali, (2014) Characterization of essential nutrients and heavy metals during municipal solid waste composting. Int. J. Innov. Res. Sci. Eng. Tech. 3 (2):9664–72.
Neugebauer, M., P. Sołowiej, J. Piechocki, W. Czekała, and D. Janczak, (2017) The influence of the C: N ratio on the composting rate. International Journal of Smart Grid and Clean Energy, 6(1), 54-60.
Paz-Ferreiro, J., H. Lu, S. Fu, A. Me´ndez, G. Gasco, (2014) Use of phytoremediation and biochar to remediate heavy metal polluted soils: a review. Solid Earth., 5:65–75.
PBBC, (2020) Pacific Biochar Benefit Corporation. Retrieved from Biochar in Composting. Available at the following address: https://pacificbiochar.com/how-to-work-with-biochar/in-composting/.
Rashwan, M. A., F. N. Alkoaik, H. A. Saleh, R. B. Fulleros and M. N. Ibrahim, (2021) Maturity and stability assessment of composted tomato residues and chicken manure using a rotary drum bioreactor. Journal of the Air & Waste Management Association, 71:5, 529-539, DOI: 10.1080/10962247.2020.1859416
Research report, (2005) Assessment of options and requirements for stability and maturity testing of composts, statistical report on test methods. by Phil Wallace, Enviros Ltd. Published by: The Waste and Resources Action Programme, The Old Academy, 21 Horse fair, Banbury, Oxon OX16 0AH, Issue 2 – www.wrap.org.uk
Saha, S., K. A. Gopinath, B. L. Mina, and H. S. Gupta, (2008) Influence of Continuous Application of Inorganic Nutrients to a Maize-Wheat Rotation on Soil Enzyme Activity and Grain Quality in a Rainfed Indian Soil. Eur. J. Soil Biol., 44, 521–531.
Senesi, N., and C. Plaza, (2007) Role of humification processes in recycling organic wastes of various nature and sources as soil amendments. Clean Air Soil Water 35, 26–41.
Shahbandeh, M., (2023) Global dates production 2010-2021, jan 23, 2023. https://www.statista.com/statistics/960247/dates-production-worldwide/
Shenbagavalli, S., and S. Mahimairaja, (2012) Characterization and effect of biochar on nitrogen and carbon dynamics in soil. Int. J. Adv. Biol. Res., 2, 249–255.
Singh, B., B. P. Singh, A. L. Cowie, (2010) Characterisation and evaluation of biochars for their application as a soil amendment. Aust. J. Soil Res., 48:516.
Sullivan, D. M., A. I. Bary, R. O. Miller, and L. J. Brewer, (2018) Interpreting compost analyses. file:///C:/Users/mrashwan.c/Downloads/Sullivanetal. Interpreting compost analyses OSU publication E M921710262018%20(1).pdf
Tiquia, S. M., (2010) Reduction of compost phytotoxicity during the process of decomposition. Chemosphere 79 (5):506–12.
Tiquia, S., N. Tam, and I. Hodgkiss, (1996) Effects of composting on phytotoxicity of spent pig-manure sawdust litter. Environ. Pollut. 93:249–56.
Usman, A. R., A. Abduljabbar, M. Vithanage, Y. Ok, M. Ahmad, M. Ahmad, J. Elfaki, A. Sallam, and M. Al-wabel, (2015) Biochar production from date palm waste: charring temperature induced changes in composition and surface chemistry. J. Analy. Appl. Pyrolosis, 115:392–400.
Wan, Q., J. H. Yuan, R. K. Xu, and H. LiX, (2014) Pyrolysis temperature influences ameliorating effects of biochars on acidic soil. Environ. Sci. Pollut. ResInt., 21:2486–95.
WEL, (2009) Woods end research laboratory, Inc. Dewar Selfheating Test. https://www.yumpu.com/en/document/view/41989225/dewar-self-heating-test-update-woods-endlaboratories
WERL, (2018) Woods end research laboratory, Inc. Guide to Solvita Testing for Compost Maturity Index. https://woodsend.com/wp-content/uploads/2019/09/Compost-Maturity-Index_CA-Compost-Quality-Council_Buchanan_Brinton_2001.pdf
Westerman, P. W., and J. R. Bicudo, (2005) Management considerations for organic wastes use in agriculture. Bioresour. Technol. 96, 215–221.
Wichuk, K. M., and D. McCartney, (2010) Compost stability and maturity evaluation-a literature review. Canadian Journal of Civil Engineering, 37(11), 1505-1523.
Zucconi, F., A. Monaco, and M. Forte, (1985) Phytotoxins during the stabilization of organic matter. In Composting of agricultural and other wastes, ed. J. K. R. Gasser, 73–86. New York: Elsevier Applied Science Publication.
Zucconi, F., A. Pera, M. Forte, and M. de Bertoldi, (1981b) Evaluating toxicity of immature compost. Biocycle 22 (4):54–57. | ||||
|
Statistics Article View: 796 PDF Download: 109 |
||||
