Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater
Abou-Elela, S., Fawzy, M., El-Sorogy, M., Abo-El-Enein, S. (2018). Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater. EKB Journal Management System, 61(4), 629-637. doi: 10.21608/ejchem.2018.3849.1333
Sohair I. Abou-Elela; Mariam E. Fawzy; Mohamed M. El-Sorogy; Salah A. Abo-El-Enein. "Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater". EKB Journal Management System, 61, 4, 2018, 629-637. doi: 10.21608/ejchem.2018.3849.1333
Abou-Elela, S., Fawzy, M., El-Sorogy, M., Abo-El-Enein, S. (2018). 'Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater', EKB Journal Management System, 61(4), pp. 629-637. doi: 10.21608/ejchem.2018.3849.1333
Abou-Elela, S., Fawzy, M., El-Sorogy, M., Abo-El-Enein, S. Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater. EKB Journal Management System, 2018; 61(4): 629-637. doi: 10.21608/ejchem.2018.3849.1333

Bio-immobilization of Cr (VI) and its Impact on the Performance of a Pilot Scale Anaerobic Sludge Reactor Treating Municipal Wastewater

Egyptian Journal of Chemistry
Article 6, Volume 61, Issue 4, July and August 2018, Page 629-637  XML PDF (846.38 K)
Document Type: Original Article
DOI: 10.21608/ejchem.2018.3849.1333
View on SCiNiTO View on SCiNiTO
Authors
Sohair I. Abou-Elela1; Mariam E. Fawzy email orcid 1; Mohamed M. El-Sorogy2; Salah A. Abo-El-Enein3
1Water Pollution Research Department, National Research Centre, Giza, 12622, Egypt.
2Holding Company for Water and Wastewater, Giza, 12577, Egypt.
3Chemistry Department, Faculty of Science, Ain Shams University, Cairo, 11566, Egypt.
Abstract
This study aimed to emphasize the effect of hexavalent chromium Cr (VI) on the performance of a pilot scale hybrid up-flow anaerobic sludge blanket (H-UASB). The system was packed with non-woven poly ester fabric (NWPF) and continuously fed with real municipal wastewater at a hydraulic retention time (HRT) 7.5 h and average organic loading rate (OLR) 1.24 Kg COD m3/d. The system achieved satisfactory removal rates for total suspended solids (TSS) (86.44 %), chemical oxygen demand (COD) (74.18 %) and biological oxygen demand (BOD5) (84.8%) without the addition of Cr (VI). Results indicated that feeding the reactor with different concentrations of chromium ions ranged from 0.1 – 1.3 mg/l (i.e: 600 mg / m3. d to 6000 mg / m3. d) decreased the residual concentration of Cr (VI) in the final effluent to 0.019 mg/l, while the accumulation of chromium ion increased in the biobed (160 mg/kg) and in excess sludge (165.44 mg/kg). This was due to the biological reduction of Cr (VI) to Cr (III) by the action of sulphate and chromate reducing bacteria. Increasing the concentration of Cr (VI) up to 6000 mg / m3. d reduce the biochemical reactions of the anaerobic microorganisms and consequently decrease the removal efficiency of TSS from 86.44% to 62.06, COD from 74.2 % to 57.07 % and BOD5 from 84.8% to 61.92%.
Keywords
anaerobic digestion; hazardous wastewater; Hexavalent chromium; hybrid up-flow anaerobic sludge blanket; non-woven polyester fabric
Statistics
Article View: 560
PDF Download: 376