THIN LAYER MODEL FOR SOLAR DRYING OF NAVEL AND MINNEOLA ORANGE SLICES | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 11, Volume 32, Issue 4, October 2015, Page 1589-1608 PDF (1.71 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2015.97754 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| B. M. A. Amer1, 2; A. H. E. Amer3, 2 | ||||
| 1Ag. Eng. Dept., Fac. of Ag., Cairo Univ., Egypt. | ||||
| 2Dept. of Ag. Systems Eng., College of Ag. & Food Sciences, King Faisal Univ., Saudi Arabia. | ||||
| 3Ag. Eng. Dept., Fac. of Ag., Minoufiya Univ. (Shibin El-Kom), Egypt. | ||||
| Abstract | ||||
| Navel and Minneola orange slices at different thickness of 3, 6 and 9 mm were dried using a forced air solar dryer and have been examined nine drying models defining thin layer drying behavior of it using statistical analysis. Therefore, the drying models have been fitted to experimental data by means of the coefficients in these models. The results display that the regression analysis was performed using the experimental data to develop a thin layer drying model. The best fit of the thin layer drying of Navel and Minneola orange slices is obtained by two-term and Page equations were selected for the mathematical modeling based on the value of R2, c2 and RMSE. Both fitted models were validated against the experimental data. | ||||
| Keywords | ||||
| Navel; Minneola; modelling; solar; drying | ||||
| References | ||||
|
Aghbashlo M., Kianmehr, M.H. & Arabhosseini, A.(2009). Modeling of thin-layer drying of potato slices in length of continuous band dryer. Energy Conversion and Management, 50, 1348–1355.
Amer, B. M. A., Hossain, M. A. & Gottschalk, K. (2010). Design and performance evaluation of a new hybrid dryer for banana. Energy Conversion and Management, 2010, 51(4): 813-820.
AOAC (2003). Official methods of analysis (16th ed.). Washington, DC, USA: Association of Official Analytical Chemists.123–135.
Benhura, C., Kugara, J., Muchuweti, M., Nyagura, S. F., Matarise, F., Gombiro, P.E. and Nyandoro, G. (2014). Drying kinetics of syrup of Parinari curatellifolia fruit and cereal based product, zvambwa. Journal of Food Science and Technology, 51:
Ben Slama, R. and Combarnous, M. (2011). Study of orange peels dryings kinetics and development of a solar dryer by forced convection. Solar Energy, 85, 570–578.
Ceylan, I., Aktas, M., and Dogan, H. (2007). Mathematical modeling of drying characteristics of tropical fruits. Applied Thermal Engineering, (27):1931–1936.
Chimplee, S., and Klinkesorn, U., (2015). Thin-layer drying model of Rambutan (Nephelium lappaceum L.) kernel and its application in fat extraction process. International Journal of Food Engineering, 11(2): 243-253.
Davies, F.S., 1997. An overview of climatic effects on citrus flowering and fruit quality in various parts of the world. In: Citrus Flowering and Fruiting Short Course, 1., Lake Alfred. Proceedings. CREC/IFAS, Lake Alfred.
Diamante, L.M., and Munro, P.A. (1993). Mathematical modeling of the thin layer solar drying of sweet potato slices. Solar Energy, 51, 271–276.
Diamante, L.M., Ihns, R., Savage, G.P., and Vanhanen, L., (2010). A new mathematical model for thin layer drying of fruits. International Journal of Food Science and Technology, 45 (9), 1956–1962.
Doymaz, I., and Pala, M. (2002). The effects of dipping pretreatments on air drying rates of the seedless grapes. Journal of Food Engineering, 52, 413–417.
Doymaz, I., andIsmail, O., (2011).Drying characteristics of sweet cherry. Food and Bioproducts Processing, 89, 31–38.
El-Beltagy A., Gamea, G.R and Amer Eissa A.H. (2007). Solar drying characteristics of strawberry. Journal of Food Engineering, 78 (2007) 456–464.
Ertekin, C., and Yaldiz, O. (2004). Drying of eggplant and selection of suitable thin layer drying model. Journal of Food Engineering 63(3), 349–359.
Gallali, Y. M., Abujnah Y. S, and Bannani F. K. (2000).Preservation of fruits and vegetables using solar drier: a comparative study of natural and solar drying, III; chemical analysis and sensory evaluation data of the dried samples (grapes, figs, tomatoes and onions). Renewable Energy,19:203–12.
Garau, M.C., Simal, S., Femenia, A. and Rossello, C. (2006). Drying of orange skin: drying kinetics modeling and functional properties. Journal of Food Engineering, 75, 288–295.
Goyal, R.K., Kingsly, A.R.P., Manikantan, M.R. and Ilyas, S.M., (2007). Mathematical modeling of thin layer drying kinetics of plum in a tunnel dryer. Journal of Food Engineering 79: 176–180.
Hii, C.L., Law, C.L. and Cloke, M. (2009). Modeling using a new thin layer drying model and product quality of cocoa. Journal of Food Engineering, 90, 191–198.
Jackson L. K. and Futch S. H. (2003). Minneola Tangelo. HS171, the Horticultural Sciences Department, UF/IFAS Extension. University of Florida. Karathanos, V.T. (1999). Determination of water content of dried fruits by drying kinetics. Journal of Food Engineering, 39(4), 337–344.
Kucerova, I., Hubackova, A., Rohilik, B. and Banout, J. (2015). Mathematical Modeling of Thin-Layer Solar Drying of Eland (Taurotragus oryx) Jerky. Int. J. of Food Eng. 11(2), 229-242. Madamba, P.S., Driscoll, R.H., and Buckle, K.A. (1996). The thin layer drying characteristics of garlic slices. Journal of Food Engineering, 29, 75–97.
Mahmutogla, T., Emir, F., and Saygi, Y. B. (1996). Sun/solar dryer of differently treated grapes and storage stability of dried grapes. Journal of Food Engineering, 29, 289–300.
Midilli A., Kucuk H. and Yapar Z. (2002). A new model for single layer drying. Drying Technology, 20: 1503-1513.
Ozdemir, M., and Devers, Y.O. (1999). The thin layer drying characteristics of hazelnuts during roasting. Journal of Food Engineering, 42, 225–233.
Rodriguez-Amaya, D.B. (1999). A guide to carotenoid analysis in foods. International life Sciences Institute Press, p.59. Washington, DC.
Sanchez-Moreno, C., Plaza, L., De Ancos, B., and Cano, M.P. (2003). Vitamin C, provitamin A carotenoids, and other carotenoids in high pressure orange juice during refrigerated storage. Journal of Agricultural and Food Chemistry, 51(3), 647–653.
Sarsavadia, P.N., Sawhney, R. L., Pangavhane, D.R., and Singh, S.P. (1999). Drying behavior of brined onion slices. Journal of Food Engineering, 40, 219–226.
Shi, Q., Zheng, Y., and Zhao, Y. (2013). Mathematical modeling on thin-layer heat pump drying of yacon (Smallanthus sonchifolius) slices. Energy Conversion and Management, 71, 208–216.
Taghian Dinani, S., Hamdami, N., Shahedi, M., and Havet, M. (2014). Mathematical modeling of hot air/electrohydrodynamic (EHD) drying kinetics of mushroom slices. (2004). Energy Conversion and Management, 86, 70–80.
Togrul, I.T. and Pehlivan, D. (2004). Modelling of thin layer drying of some fruits under open-air sun drying process. Journal of Food Science and Technology, 65:413-425.
Turner, I., and Mujumdar, A.S. (1997). Mathematical modeling and numerical techniques in drying technology. Marcel Dekker. New York.
Yagciolu, A., Degirmencioglu, A. and Cagatay, F. (1999). Drying characteristics of laurel leaves under different conditions. In Proceedings of the 7th International Congress on Agricultural Mechanization and Energy, May, Adana, Turkey (pp. 565–569).
Yaldiz, O., Ertekin, C., and Uzun, H.I. (2001). Mathematical modeling of thin layer solar drying of sultara grapes. Energy, 26, 457–465. | ||||
|
Statistics Article View: 144 PDF Download: 203 |
||||
