BIO-ETHANOL APPLICATION AS AN ALTERNATIVE FUEL IN FARM MACHINE | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 3, Volume 31, Issue 4, October 2014, Page 1277-1290 PDF (1.11 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2014.98230 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| M. E. Sehsah1; E.B. Belal2; R.R. Abu shieshaa3; A. Ellawaty4 | ||||
| 1Associate Prof, Agric. Eng. Dept., Fac. Of Agric., Kafr EL Sheikh Univ. Egypt. | ||||
| 2Prof.Dr. Microbiolog Dev. Botany . Dept., Fac. Of Agric., Kafr EL Sheikh Univ. Egypt. | ||||
| 3head of research Prof.Dr. Agric. Eng. At. Eng. Res. Institute. Dokki., giza. Egypt. | ||||
| 4Post- graduate student, Agric. Eng. Dept., Fac. Of Agric., Kafr EL Sheikh Univ. Egypt. | ||||
| Abstract | ||||
| The current research is the second part from study of the bioethanol production under local conditions. The experiments were carried out at the agricultural engineering laboratory, Agricultural Engineering Department, faculty of Agriculture, Kafr El Sheikh University. The experimental aimed to investigate of the possibility to use an alternative fuel for gasoline engine by using various ratios from bioethanol and gasoline. The bioethanol was produced after microbial pre-treatment for starcheous liquid of potato wastes and subsequent fermentation with Saccharomyces cerevisae under laboratory conditions. The blend fuel E10, E30 and E60 were prepared and used at three throttle fuel positions .The engine model Mikuni 13.5 KW at the maximum rotational speed 3600 rpm tested under different blend fuel. The result showed that the Gasoline with octane 80 Nr. gave the highest values of treatments for piston sprayer pump and gasoline engine compared to the E10, E30 and E60 of fuel blend, respectively. The engine break horse power at the second fuel throttle position and with load of engine were 6.9 KW, 6.8 KW and 6.9 KW for the fuel blend E10, E30 and the gasoline Octane 80. The fuel blend E10 and E30 gave no significant different compared with the gasoline Octane 80 fuel on the effect of the rotational speed under all treatment conditions. The operating of the engine with load gave the highest values of noise of the engine compared to operate the engine without load for all blend fuel and Gasoline fuel tests. The blend fuel E60 gave the low values of sound level compared to the other blend fuel and Gasoline fuel. On the other hand, the effect of the increasing of throttle position from first to third position those mean the increasing of fuel flow rate tends to increase the sound level. The lower values of noise pollution of the engine were 68.1 dB, 78.8 dB and 81.7 dB for the fuel blend E60 with load at first, second and third fuel throttle position respectively. | ||||
| Keywords | ||||
| Biofuel; bioethanol and piston sprayer pump | ||||
| References | ||||
|
Baiju, B., M. K Naik, and L. M. Das. (2009). A comparative evaluation ocompression ignition characteristics using methyl and ethyl esters of karanja oil. Renewable Energy 34(6): 1616-1621.
Bala, B. K. (2005). Studies on biodiesels from transformation of vegetable oils for diesel engines. Energy Edu. Sci. Technol. 15:1–43.
Baylis, A. D. (2008). Biofuels: what impact on crop protection and seeds now? Part 1: Current status of biofuels and crop feedstocks. Outlooks on Pest Management, 19(5), 217-9.
Demirbas, A. (2005). Bioethanol from cellulosic materials: A renewable motor fuel from biomass. Energy Sources 27:327–337.
Farrell, A. E., (2006). Ethanol can contribute to energy and environmental goals. Science 311: 506-508.
Gallagher, E. (2008). Report of the Gallagher Review of the indirect effects of biofuel production. UK Renewable Fuels Agency: St Leonards-on-Sea, UK.
Granda Cesar B., (2007). Sustainable liquid biofuels and their environmental impact. Environmental Progress 26: 233-250.
IEA. (1999). Automotive fuels for the future. The Search for Alternatives. Inter National Energy Agency.
Kim, S., and Dale, B. E., (2005). Environmental aspects of ethanol derived from non-tilled corn grain: non-renewable energy consumption and greenhouse gas emissions. Biomass & Bioenergy 28: 475-489.
Lang, X., Macdonald, D. G., and Hill, G. A. (2001). Recycle bioreactor for bioethanol production from wheat starch. II. Fermentation and economics. Energy Sources 23:427–436.
Licht, F.O. (2006). World Ethanol Market: The Outlook to 2015, Tunbridge Wells, Agra Europe Special Report, UK.
Mabee, W. E. (2007). Policy Options to Support Biofuel Production. Pages 329-357. Biofuels.
Sehsah E E, M A Helmy and H M Soror. (2010). Noise test of tow manufactured power tillers during transport on different local road conditions. Int J Agric & Biol Eng, 3 (4): 19-27.
Solomon, B. D., (2007). Grain and cellulosic ethanol: History, economics, and energy policy. Biomass & Bioenergy 31: 416-425.
Srivastava, A. K., Goering, C. E., and Rohrbach., R. P. (1993). Engineering Principles of Agricultural Machines. ASAE Textbook No. 6. St. Joseph, MI: ASAE.
Thummarat, T. (2008).E10, E20, E30 ; Effects on Tailpipe Emissions, Vehicle Performance and Hot Weather Drivability 6’th Asian Petroleum Technology Symposium, Cebu, Philippines. | ||||
|
Statistics Article View: 153 PDF Download: 472 |
||||
