SLURRY TREATMENT WITH FOOD INDUSTRY WASTES FOR REDUCING METHANE, NITROUS OXIDE AND AMMONIA EMISSIONS | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 17, Volume 31, Issue 4, October 2014, Page 1523-1548 PDF (1.13 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2014.98406 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| M. Samer1; E. Mostafa2; A. M. Hassan2 | ||||
| 1Assoc. Prof., Ag. Eng. Dept., Fac. of Agric., Cairo University, Egypt. | ||||
| 2Assist. Prof., Ag. Eng. Dept., Fac. of Agric., Cairo University, Egypt. | ||||
| Abstract | ||||
| Livestock manure is the main source of ammonia (NH3) emissions and an important source of greenhouse gases (GHG) especially methane (CH4) and nitrous oxide (N2O). Ammonia emissions contribute to eutrophication and acidification of water, soils and ecosystems. The greenhouse gases contribute to the global warming. These gaseous emissions can be reduced by controlling the pH-value of manure. Acidifying the manure can reduce CH4, N2O and NH3 emissions. Inorganic acids are feasible, but have several disadvantages, e.g. soil contaminants. The use of organic acids is an efficient but expensive method; therefore using the food industry wastes which already contain organic acids is highly feasible. The objective of this research is to investigate the effects food industry wastes as manure additives on the emissions of CH4, N2O and NH3. Dairy cattle manure was treated with food industry wastes (whey and waste of citrus and orange juices industry) and the gas flux of CH4, N2O and NH3 were quantified using a specially designed gas detection system which consists of several flasks and a multi-gas monitor. The results showed that the gas fluxes emitted from manure treated with waste of citrus juice industry were 13, 0.219 and 2.523 g m-2 day-1 for CH4, N2O and NH3 respectively. The gas fluxes emitted from manure treated with waste of orange juice industry were 13.58, 0.223 and 2.581 g m-2 day-1 for CH4, N2O and NH3 respectively. The gas fluxes emitted from manure treated with whey were 17.45, 0.279 and 3.063 g m-2 day-1 for CH4, N2O and NH3 respectively. The gas fluxes emitted from the control sample (mixture of manure and water) were 58.21, 0.347 and 18.9 g m-2 day-1 for CH4, N2O and NH3 respectively. Consequently, manure treatment with food industry wastes enabled high reduction rates of gaseous emissions from manure. | ||||
| Keywords | ||||
| Manure management; slurry treatment; food industry wastes; emissions abatement techniques; emission factors; greenhouse gases; ammonia; methane; nitrous oxide | ||||
| References | ||||
|
Al-Kanani, T., E. Akochi, A.F. Mackenzie, I. Alli, and S. Barrington. 1992. Organic and inorganic amendments to reduce ammonia losses from liquid hog manure. Journal of Environmental Quality, 21, 709–715.
Beck, J., Burton, C., 1998. Manure treatment techniques in Europe—result of a EU Concerted Action. In: Proceedings of the International Conference on Agricultural Engineering, AgEng 98, Oslo, Norway, August 24–27, pp. 211–212.
Berg, W., 2003. Reducing ammonia emissions by combining covering and acidifying liquid manure. In: Proceedings of the Third International Conference on Air Pollution from Agricultural Operations, Raleigh, NC, USA, October 12–15, pp. 174–182.
Berg, W., 1999. Technology assessment—livestock management. Anim. Res. Dev. 50, 98–109.
Berg, W., Hoernig, G., 1997. Emission reduction by acidification of slurry—investigations and assessment. In: Voormans, J.A.M., Monteny, G.J. (Eds.), Proceedings of the International Symposium on Ammonia and Odour Control from Animal Production Facilities, Vinkeloord, The Netherlands, October 6–10, pp. 459–466.
Berg, W., Pazsiczki, I., 2003. Reducing emissions by combining slurry covering and acidifying. In: Proceedings of the International Symposium on Gaseous and Odour Emissions from Animal Production Facilities, Horsens, Denmark, June 1–4, pp. 460–468.
Berg, W., R. Brunsch, and I. Pazsiczki. 2006a. Greenhouse gas emissions from covered slurry compared with uncovered during storage. Agriculture, Ecosystems and Environment, 112 (2-3), 129–134.
Berg, W., M. Türk, and J. Hellebrand. 2006b. Effects of Acidifying Liquid Cattle Manure with Nitric or Lactic Acid on Gaseous Emissions. Workshop on Agricultural Air Quality – State of the Science. Potomac, MD, USA. 5–8 June 2006. 492–498.
FAO. 2006. Livestock's role in climate change and air pollution. Available at: ftp://ftp.fao.org/docrep/fao/010/a0701e/A0701E03.pdf. Accessed December 2010.
Hartung, J. and V.R. Phillips. 1994. Control of gaseous emissions from livestock buildings and manure stores. Journal Agricultural Engineering Research, 57, 173–189.
Hendriks, J.G.L., Vrielink, M.G.M., 1997. Reducing ammonia emission from pig houses by adding or producing organic acids in pig slurry. In: Voormans, J.A.M., Monteny, G.J. (Eds.), Proceedings of the International Symposium on Ammonia and Odour Control from Animal Production Facilities, Vinkeloord, The Netherlands, October 6–10, pp. 493–501.
Houghton, J.T., L.G. Meira Filho, B. Lim, K. Treanton, I. Mamaty, Y. Bonduki, D.J. Griggs, B.A. Callender (Eds.). 1997. Revised 1996 IPCC Guidelines for National Greenhouse Gas Inventories. IPCC/OECD/IEA. UK Meteorological Office, Bracknell.
Husted, S., L.S. Jensen, and S.S. Jorgensen. 1991. Reducing ammonia loss from cattle slurry by the used of acidifying additives: the role of the buffer system. Journal of the Science of Food and Agriculture, 57, 335–349.
IPCC. 2007. Climate Change 2007: Mitigation. Contribution of Working Group III to the 4th Assessment Report of the Intergovernmental Panel on Climate Change. B. Metz, O. R. Davidson, P. R. Bosch, R. Dave, and L. A. Meyer, eds. Cambridge University Press, Cambridge, United Kingdom and New York, NY, USA.
Kroodsma, W., Ogink, N.W.M., 1997. Volatile emissions from cow cubicle houses and its reduction by immersion of the slats with acidified slurry. In: Voormans, J.A.M., Monteny, G.J. (Eds.), Proceedings of the International Symposium on Ammonia and Odour Control from Animal Production Facilities, Vinkeloord, The Netherlands, October 6–10, pp. 475–483.
Lay, J.J., Y.Y. Li, and T. Noike. 1997. Influences of pH and moisture content on the methane production in high-solids sludge digestion. Water Research, 31 (6), 1518–1524.
Li, H., H. Xin, and R.T. Burns. 2006. Reduction of ammonia emission from stored poultry manure using additives: zeolite, Al+ clear, Ferix-3, and PLT. ASAE Paper No. 064188, 2006 ASABE Annual International Meeting, Portland, OR, USA.
Martinez, J., Jolivet, J., Guiziou, F., Langeoire, G., 1997. Ammonia emissions from pig slurries: evaluation of acidification and the use of additives in reducing losses. In: Voormans, J.A.M., Monteny, G.J. (Eds.), Proceedings of the International Symposium on Ammonia and Odour Control from Animal Production Facilities, Vinkeloord, The Netherlands, October 6–10, pp. 485–492.
Oenema, O., Velthof, G.L., 1993. Denitrification in nitric-acid-treated cattle slurry during storage. Neth. J. Agric. Sci. 41, 63–80.
Pain, B.F., R.B. Thompson, Y.J. Rees, and J.H. Skinner. 1990. Reducing gaseous losses of nitrogen from cattle slurry applied to grassland by the use of additives. Journal of the Science of Food and Agriculture, 50, 141–153.
Pedersen, P., 2003. Reduction of gaseous emissions from pig houses by adding sulphuric acid to the slurry. In: Proceedings of the International Symposium on Gaseous and Odour Emissions from Animal Production Facilities, Horsens, Denmark, June 1–4, pp. 257–263.
Raghav R., N. Yadav, G. Tyagi, D.K. Jangir, R. Mehrotra, R. Ganesan, E.S. Rajagopal. 2012. Degradation studies of organic acids in commercially packed fruit juices: A reverse phase high performance liquid chromatographic approach. International Journal of Food Engineering, DOI: 10.1515/1556-3758.1821.
Reinhardt-Hanisch, A. 2008. Grundlagenuntersuchungen zur Wirkung neuartiger Ureaseinhibitoren in der Nutztierhaltung (Basic research on the effects of novel urease inhibitors in animal housing). PhD diss. Stuttgart, Germany: University of Hohenheim.
Samer, M. 2013a. Emissions inventory of greenhouse gases and ammonia from livestock housing and manure management. Agricultural Engineering International: CIGR Journal, Vol. 15(3): 29－54.
Samer, M. 2013b. Towards the implementation of the Green Building concept in agricultural buildings: a literature review. Agricultural Engineering International: CIGR Journal, Vol. 15(2): 25-46.
Samer, M., C. Ammon, C. Loebsin, M. Fiedler, W. Berg, P. Sanftleben, and R. Brunsch. 2012. Moisture balance and tracer gas technique for ventilation rates measurement and greenhouse gases and ammonia emissions quantification in naturally ventilated buildings. Building and Environment, Vol. 50(4): 10-20.
Samer, M. 2012. Effect of airflow profile on reducing heat stress, enhancing air distribution and diluting gaseous concentrations in dairy barns. Misr Journal of Agricultural Engineering, Vol. 29(2): 837-856.
Samer, M., C. Loebsin, K. von Bobrutzki, M. Fiedler, C. Ammon, W. Berg, P. Sanftleben, and R. Brunsch. 2011a. A computer program for monitoring and controlling ultrasonic anemometers for aerodynamic measurements in animal buildings. Computers and Electronics in Agriculture, Vol. 79(1): 1-12.
Samer, M., C. Loebsin, M. Fiedler, C. Ammon, W. Berg, P. Sanftleben, and R. Brunsch. 2011b. Heat balance and tracer gas technique for airflow rates measurement and gaseous emissions quantification in naturally ventilated livestock buildings. Energy and Buildings, Vol. 43(12): 3718-3728.
Samer, M. 2011a. How to construct manure storages and handling systems? IST Transactions of Biosystems and Agricultural Engineering, Vol. 1(1): 1-7.
Samer, M. 2011b. Seasonal variations of gaseous emissions from a naturally ventilated dairy barn. Misr Journal of Agricultural Engineering, Vol. 28(4): 1162-1177.
Samer, M. 2010. A software program for planning and designing biogas plants. Transactions of the ASABE, Vol. 53(4): 1277-1285.
Samer, M., H. Grimm, M. Hatem, R. Doluschitz, and T. Jungbluth. 2008a. Mathematical modeling and spark mapping for construction of aerobic treatment systems and their manure handling system. Proceedings of International Conference on Agricultural Engineering, Book of Abstracts p. 28, EurAgEng, June 23-25, Hersonissos, Crete, Greece.
Samer, M., H. Grimm, M. Hatem, R. Doluschitz, and T. Jungbluth. 2008b. Mathematical modeling and spark mapping of dairy farmstead layout in hot climates. Misr Journal of Agricultural Engineering, Vol. 25 (3): 1026 -1040.
Schuurkes, J., and R. Mosello. 1988. The role of external ammonium inputs in freshwater acidification. Aquatic Sciences – Research Across Boundaries, 50(1): 71-86.
Shah S. B. and P. Kolar. 2012. Evaluation of additive for reducing gaseous emissions from swine waste. Agric. Eng. Int.: CIGR Journal, Vol. 14(2): 10-20.
Sommer, S.G., Christensen, B.T., Nielsen, N.E., Schjorring, J.K., 1993. Ammonia volatilization during storage of cattle and pig slurry—effect of surface cover. J. Agric. Sci. 121, 63–71.
Sommer, S.G., Pedersen, S.O., Sogaard, H.T., 2000. Greenhouse gas emissions from stored livestock slurry. J. Environ. Qual. 29, 744–751.
Stevens, R.J., R.J. Laughlin, and J.P. Frost. 1989. Effect of acidification with sulphuric acid on the volatilization of ammonia from cow and pig slurries. Cambridge Journal of Agricultural Science, 113, 389–395.
Wheeler, E.F., M.A.A. Adviento-Borbe, R.C. Brandt, P.A. Topper, D.A. Topper, H.A. Elliott, R.E. Graves, A.N. Hristov, V.A. Ishler, and M.A.V. Bruns. 2011a. Amendments for mitigation of dairy manure ammonia and greenhouse gas emissions: preliminary screening. Agricultural Engineering International: CIGR Journal, 13(2): 1-14.
Wheeler, E.F., M.A.A. Adviento-Borbe, R.C. Brandt, P.A. Topper, D.A. Topper, H.A. Elliott, R.E. Graves, A.N. Hristov, V.A. Ishler, M.A.V. Bruns. 2011b. Evaluation of odor emissions from amended dairy manure: preliminary screening. Agricultural Engineering International: CIGR Journal, 13(2): 15-29.
Wheeler, E.F., P.A. Topper, R.C. Brandt, N.E. Brown, A. Adviento-Borbe, R.S. Thomas, and G.A. Varga. 2011c. Multiple-Chamber Instrumentation Development for Comparing Gas Fluxes from Biological Materials. Applied Engineering in Agriculture, 27(6): 1049-1060.
Williams, A., 2003. Floating covers to reduce ammonia emissions from slurry. In: Proceedings of the International Symposium on Gaseous and Odour Emissions from Animal Production Facilities, Horsens, Denmark, June 1–4, pp. 283–291. | ||||
|
Statistics Article View: 238 PDF Download: 227 |
||||
