PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL
Mosallam, M., Tayel, S., Zaalouk, A., Mousa, A. (2015). PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL. EKB Journal Management System, 32(2), 451-468. doi: 10.21608/mjae.2015.98574
M. A. Mosallam; Samir A. Tayel; A. K. Zaalouk; A. M. Mousa. "PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL". EKB Journal Management System, 32, 2, 2015, 451-468. doi: 10.21608/mjae.2015.98574
Mosallam, M., Tayel, S., Zaalouk, A., Mousa, A. (2015). 'PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL', EKB Journal Management System, 32(2), pp. 451-468. doi: 10.21608/mjae.2015.98574
Mosallam, M., Tayel, S., Zaalouk, A., Mousa, A. PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL. EKB Journal Management System, 2015; 32(2): 451-468. doi: 10.21608/mjae.2015.98574

PRODUCTION OF BIODIESEL FROM WASTE VEGETABLE OIL USING A BENCH SCALE STIRRED VESSEL

Misr Journal of Agricultural Engineering
Article 4, Volume 32, Issue 2, April 2015, Page 451-468  XML PDF (785.17 K)
Document Type: Original Article
DOI: 10.21608/mjae.2015.98574
View on SCiNiTO View on SCiNiTO
Authors
M. A. Mosallam1; Samir A. Tayel1; A. K. Zaalouk2; A. M. Mousa3
1Prof. of Ag. Eng. - Fac. of Ag. Eng. - Cairo - Al-Azhar Univ., Egypt.
2Assoc. Prof. of Ag. Eng. - Fac. of Ag. Eng. - Cairo - Al-Azhar Univ., Egypt.
3Assist. Lecturer of Ag. Eng. - Fac. of Ag. Eng. - Cairo - Al-Azhar Univ., Egypt.
Abstract
This study aims to the production of biodiesel from a waste vegetable oil (WVO) using methyl alcohol and sodium hydroxide. The oil used is a mixture of soybean oil and sunflower with ratio 1:1. This oil is reminder of frying process. The study included the stirred vessel operating conditions and relative dimensions. The study was carried out under batch system using a bench scale stirred vessel. The study ended by: the ratio between the reactants; oil: alcohol: catalyst = 100 cm3: 25 cm3: 1 g, 500 rpm stirring speed and 15 min stirring time. The production is carried out under ambient temperature given that this temperature is 30o C or more. Volume of the batch has no detectable effect on the production. The stirred vessel used for the production is without baffles.
Relating to the diameter of the vessel "D" diameter of the impeller was 1/2 D, clearance 1/5.3 D and width of impeller 1/8 D
References
Ahmad M., S. Rashid, M.Khan, M. Zafar, S. Sultana and S. Gulzar (2009).Optimization of base catalyzed transesterification of peanut oil biodiesel. African J. Biotec., 8 (3): 441- 446.

Arévalo B., B. Facio, A. Jiménez, E. Rogel-Hernández, and H. Espinoza-Gómez (2008). The production of biodiesel from blended commercial oil in Mexico: A Comparative Study. J. Mex. Chem. Soc., 52 (2): 136-139.

Arjun B., K. Chris and M. Rafiqul (2008). Waste cooking oil as an alternate feedstock for biodiesel production. Canada - Energies., 1: 3 - 18.

Berrios M., M. Martín, A. Chica, and A. Martín (2010). Study of esterification and transesterification in biodiesel production
from used frying oils in a closed system. Spain- Chem. Eng. J., 160: 473 - 479

El Diwani G., N. Attia and S. Hawash (2009). Development and evaluation of biodiesel fuel and by-products from jatropha oil. Egypt - Int. J. Environ. Sci. Tech., 6 (2): 219-224.

Encinar J., J. Gonzalez and A. Reinares (2005). Biodiesel from used frying oil. Variables affecting the yields and characteristics of the biodiesel. Ind. Eng. Chem. Res., 44 (15): 5491 - 5499.

Encinar J., J. GonzÁlez, A. Pardal and G. Martínez (2010). Transesterification of rapeseed oil with methanol in the presence of various solvents. 3rd I. Symp. En. from Biomass and Waste Venice, Italy,: 8 - 11.

Food Balance Sheet (2012). Economic Affairs Sector, Ministry of Agriculture and Land Reclamation – in Egypt.

Guo Y., Y. Leung., and C. Koo (2002). A clean biodiesel fuel produced from recycled oils and grease trap oils. Dept. of Mec. Eng., U. Hong Kong.

Jakobsen A., M. Mork and A. Grislingås (2013).Stirred tank reactors, Lec. notes in subject SIK 2053 Reactor tec. Dept. of Chemi.
Eng. -Norwegian U. of Sc. and Tec. Downloaded from:
(http://www.nt.ntnu.no/users/jakobsen/TKP4145/stirred_tank_reactors.pdf).

Kuwornoo D. and  J. Ahiekpor (2010). Optimization of factors affecting the production of biodiesel from crude palm kernel oil and ethanol. Ghana – J.  En. & Env., 1 (4): 675 - 682.

Lean G. (2007). Oil and gas may run short by 2015. The Independent, UK.http://www.independent.co.uk/environment/climate-change/oil-and-gas-may-run-short-by-2015-say-industry-experts-458227.html

Leung D. and Y. Guo (2006). Transesterification of neat and used frying oil: Optimization for biodiesel production. China - Fuel Proc. Tec. 87: 883 – 890.

Ma F., L. Clements and M. Hanna (1998). The effect of catalyst, free fatty acids, and water on transesterification of beef tallow. Trans. of the ASAE., 41(5): 1261-1264.

Math M. and G. Irfan (2007).Optimization of restaurant waste oil methyl ester yield. J. Sci. Indian Res., 66: 772 - 776. 

Math M., S. Kumar and S. Chetty (2010). Optimization of biodiesel production from oil and fats with high free fatty acids. J. Sci. Indian Res., 3 (3): 318 - 321.

McCabe W. L., J. C. Smith and P. Harriott (1993). Unit Operations of Chemical Engineering, 5th ed.  McGraw-Hill, Handbk. - ch. (9): 235- 285.

Meher L., D. Sagar, S. Naik (2006). Technical aspects of biodiesel production by transesterification. A review. India - Renewable and Sust. En. Reviews., 10 (3): 248 - 268.

Meng X., G. Chen and Y. Wang (2008). Biodiesel production from waste cooking oil via alkali catalyst and its engine test. Fuel Proc. Tech., 89 (9): 851 - 857.

Morais S., T. Mata, A. Martins, G. Pinto and C. Costa (2010). Simulation and life cycle assessment of process design alternatives for biodiesel production from waste vegetable oils. Portugal – J. Cleaner Prod., 18: 1251-1259.

Pinzi S., J. Mata-Granados, F. Lopez-Gimenez, M. Castro, M. Dorado (2011). Influence of vegetable oils fatty-acid composition on biodiesel optimization. Spain - Bioresource Tec., 102: 1059 - 1065.

Refaat A. A (2010). Different techniques for the production of biodiesel from waste vegetable oil. Int. J. Environ. Sci. Tech., 7 (1): 183-213.

Reyes J. F., P.E. Malverde., P.S. Melin and J.P. De Bruijn (2010). Biodiesel production in a jet flow stirred reactor., Chile – En. Fuels 89: 3093 - 3098.

Sarantopoulos I., F. Che., T. Tsoutsos., V. Bakirtzoglou., W.  Azangue., D. Bienvenue and   F. Ndipen (2009). An evaluation of a small-scale biodiesel production technology: Case study of Mango’o village, Center province. Cameroon - Physics and Chem. Earth., 34: 55 - 58.

Schuchardt U., R. Serchelia and R. Matheus (1998). Transesterification of vegetable oils: A review, J. Brazil. Chem. Soc., 9 (1): 199 - 210.

Shoukry H. and M. Mosallam (2010).Effect of stirring speed and reaction time on Sunflower biodiesel production. Misr J. Ag. Eng., 28 (4): 1434 - 1444.

Tatterson G. B. (1991). Fluid mixing and gas dispersion in agitated tanks, McGraw-Hill, P: 3 (C. F. Jakobsen et al. (2013)).

Ugheoke B., D. Patrick, H. Kefas and E. Onche (2007). Determination of optimal catalyst concentration for maximum biodiesel yield from tigernut (Cyperus Esculentus) oil., Leonardo J. Sci., (10): 131 - 136.

Vicente G., M. Martínez and J.Aracil (2004). Integrated biodiesel production: a comparison of different homogeneous catalysts systems. Spain - Bioresource Tec.., 92: 297 - 305.

West A, D. Posarac and N. Ellis (2008). Assessment of four biodiesel production processes using HYSYS.Plant. Canada - Bioresource Technology., 99: 6587 - 6601.

Statistics
Article View: 120
PDF Download: 182