UTILIZATION OF CORN RESIDUES FOR WATER FILTRATION AT FISH TANKS | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 27, Volume 32, Issue 2, April 2015, Page 863-884 PDF (1010.29 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2015.98660 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| A. M. A EL-Sheikha1; M. A. Al- Rajhi2 | ||||
| 1Lecturer. Ag. Eng. Dept., Fac. of Ag. Damietta University, Egypt. | ||||
| 2Researcher, Ag. Eng. Res. Institute, AnERI, ARC. El-Doki-Egypt. | ||||
| Abstract | ||||
| Filtration has been widely used in re-circulating aquaculture system to remove waste. However, the study of some agricultural residues (corn) usage as the filter medium has not yet been studied. Therefore, the aim of this study is to construct a filter made from inexpensive and readily available corn residues and to analyze its effectiveness in controlling suspended solids that directly impact health of fish through abrasion of gill tissues or indirectly through water quality deterioration. The performance evaluation procedure was carried out in an aquaculture system with production in glass tanks located indoor in laboratory at Faculty of Agriculture, Damietta University, Egypt. The evaluation included three concentrations of total suspended solids (450, 900 and 1350 mg/l); four residues particle size distribution (3.35, 9.53, 12.7 mm and ascending order to mentioned sizes from bottom to top); and four thicknesses of filter layer (9, 21, 33 and 45 cm). The effectiveness of this filter was measured by determining filter efficiency (ηf), % and filtration rate (FR), ml/min. It was observed that the maximum value of (ηf), % was achieved at 450 mg/l concentration of total suspended solids, ascending order to sizes from bottom to top and 45 cm thickness of filtration layer. The maximum value of filtration rate was achieved at 450 mg/l concentration of total suspended solids, 12.7 mm particle size distribution and 9 cm thickness of filter layer. Results indicated that this filter is efficient enough to remove suspended solids. Therefore, this milled corn residues filter can be used in aquaculture systems for Nile tilapia, Oreochromis niloticus culture system. | ||||
| Keywords | ||||
| Agricultural residues; corn; filter; re-circulating aquaculture system; total suspended solids; filtration rate | ||||
| References | ||||
|
Ackefors, H., Enell, M., 1994. The release of nutrients and organic matter from aquaculture systems in Nordic countries. J. Appl. Ichthyol. 10, 225–241.
Agricultural Statistics ,2007. Economic Affairs Sector. Ministry of Agr. and Land Rec. Cairo, Egypt.
ASAE ,2001. Methods of determining and expressing fineness of feed materials by sieving. American Society of Agricultural Engineering standards, 45th Ed. S 319.3 , St. Joseph, Mich.
Alabaster JS and Lloyd R., 1982. Water quality criteria for freshwater fish. 2nd Edition, Food and Agriculture Organization of the United Nations, Butterworth's, London.
Amirkolaie, A.K., 2005. Dietary carbohydrate and faecal waste in the Nile tilapia (Oreochromis niloticus L.). PhD dissertation. University Wageningen, Wageningen, The Netherlands.
Bergheim, A., Cripps, S.J., Liltved, H., 1998. A system for the treatment of sludge from land-based fish-farms. Aquat. Liv. Res. 11, 279–287.
Brune,D.E., Schwartz, G., Eversole,A.G., Collier, J.A., Schwedler, T.E., 2003. Intensification of pond aquaculture and high rate photosynthetic systems. Aquac. Eng. 28, 65–86.
Buentello JA, Gatlin III DM, Neill WH., 2000. Effects of water temperature and dissolve oxygen on daily feed consumption, feed utilization and growth of channel catfish (Ictalurus punctatus). Aquaculture, 182: 339-352.
Bullock, G.L., Summerfelt, S.T., Noble, A., Weber, A.W., Durant, M.D., Hankins, J.A., 1997. Ozonation of a recirculating rainbow trout culture system: I. Effects on bacterial gill disease and heterotrophic bacteria. Aquaculture 158, 43–55.
Central Agency for Public Mobilization and Statistcs. 2011. MOAL,Egypt.
Chen, S., Coffin, D.E., Malone, R.F., 1993a. Production, characteristics, and modeling of aquacultural sludge from a recirculating aquacultural system using a granular media biofilter. In: Wang, J. (Ed.), Techniques for Modern Aquaculture. Proceedings of an Aquacultural Engineering Conference, 21–23 June 1993, Spokane, WA. American Society of Agricultural Engineers, St Joseph, MI, pp. 16–25.
Chen, S., Stechey, D., Malone, R.F., 1994. Suspended solids control in recirculating aquaculture systems. In: Timmons, M.B. and Losordo, T.M. (Eds.) Aquaculture Water Reuse Systems: Engineering Design and Management, 61-100. Elsevier, Oxford.
Chen, S. and R.F. Malone., 1991. Suspended solids control in recirculating aquacultural systems. Pp. 170-186. in Engineering aspects of intensive aquaculture. Northeast Regional Agricultural Engineering Service, Ithaca, New York.
Chen, S., Timmons, M.B., Aneshansley, D.J., Bisogni, J.J., 1993b. Suspended solids characteristics from recirculating aquacultural systems and design implications. Aquaculture 112, 143–155.
Cripps S.J. and Bergheim A., 2000. Solids management and removal for intensive land-based aquaculture production systems. Aquacultural Engineering 22 (2000) 33–56.
Cripps, S.J., Kelly, L.A., 1996. Reductions in wastes from aquaculture. In: Baird, D.J., Beveridge, M.C.M., Kelly, L.A., Muir, J.F. (Eds.), Aquaculture and Water Resource Management. Blackwell, Oxford, pp. 166–201.
Davidson, J., Good, C., Welsh, C., Brazil, B., Summerfelt, S., 2009. Heavy metal and waste metabolite accumulation and their potential effect on rainbow trout performance in a replicated water reuse system operated at low or high system flushing rates Aquacult. Eng. 41, 136-145.
Davis, J. T., 1990. Red Drum Brood Stock and Hatchery Production. SRAC Publication No.323, p. 4.
Eding, E.H., Kamstra, A., Verreth, J.A.J., Huisman, E.A., Klapwijk, A., 2006. Design and operation of nitrifying trickling filters in recirculating aquaculture: A review. Aquacult. Eng. 34, 234-260.
FAO. , 2012. The State of World Fisheries and Aquaculture; Food and Agriculture Organization of the United Nations: Rome, Italy, 2012. http://www.fao.org/ docrep/016 /i2727e/i2727e00.htm. Flemish government, 2005. Afvalwaterproblematiek op melkveebedrijven.Flemish Government, Department Agriculture and Fisheries, Department Sustainable Agricultural Development, Belgium. 61 pp.
Goldburg, R. J., Elliott, M. S. & Naylor, M. A., 2001. Marine Aquaculture in the United States: Environmental Impacts and Policy Options. Pew Oceans Commission, Arlington, VA, p. 44.
Guerdat T. C., T. M. Losordo, J. J. Classen, J. A. Osborne and D. P. DeLong, 2009. An Evaluation of Commercially Available Biological Filters for Recirculating Aquacul- ture Systems. Aquacultural engineering, Vol. 42, No. 1, 2010, pp. 38-49. doi:10.1016/j.aquaeng.2009.10.002.
Helfman, G.S., Collette, B.B., Facey, D.E., 1997. The Diversity of Fishes. Blackwell publishing, Malden, USA. 1006 pp.
Helmy, M.A; A.A. Abd EL-Rhman; M.T. Ebaid and M.A. Hassan (2003). Expectant production of biogas and fertilizer from different residues fermentation using biogas unit. Misr J.Ag.Eng., 20(4): 949- 964.
Hussenot, J.M.E., 2003. Emerging effluent management strategies in marine fish-culture farms located in European coastal wetlands. Aquaculture 226, 113–128.
Jabatan Perikanan, 1984. Water quality for aquaculture in Malaysia. In: Risalah Perikanan Bil.20,Kementerian Pertanian Malaysia, Kuala Lumpur.
Landau, M., 1992. Introduction to Aquaculture. Wiley, New York, p. 440.
Lawson, T.B., 1995. Fundamentals of Aquacultural Engineering. Chapman and Hall, New York. 355 pgs
Lee, P.G., 1993. Computer automation for recirculating systems. In: Wang, J.K. (Ed.), Proceedings of an Aquacultural Engineering Conference, 21–23 June 1993. American Society of Agricultural Engineers, St. Joseph, MI, pp. 61–70.
Libey, G.S., 1993. Evaluation of a drum filter for removal of solids. Pp. 519-532 in J.K. Wang, editor. Techniques for modern aquaculture. American Society of Agricultural Engineers, St. Joseph, Michigan.
Liltved, H., Cripps, S.J., 1999. Removal of particle associated bacteria by prefiltration and ultraviolet irradiation. Aquacult. Res. 30, 445–450.
Losordo, T.M., Westers, H., 1994. System carrying capacity and flow estimation. In: Timmons, M.B., Losordo, T.M. (Eds.), Aquaculture Water Reuse Systems: Engineering Design and Management. Elsevier, Amsterdam, pp. 9–60.
Magor, B.G. 1988. Gill histopathology of juvenile Oncorhynchus kisutch exposed to suspended wood debris. Can. J. Zool. 66: 2164-2169.
Malone, R.F., Beecher, L.E., DeLosReyes, A.A., 1998. Sizing and management of floating bead bioclarifiers. In: Libey, G.S., Timmons, M.B. (Eds.), Proceedings of the Second International Conference on Recirculating Aquaculture, 16–19 July 1998, Roanoke, USA, pp. 319–341.
Minitab Reference Manuel (release 15), Minitab Inc. State University Michigan.
Naylor R. L., R. J. Goldburg, J. H. Primavera, N. Kaustky, M. C. M. Beveridge, J. Clay, C. Folke, J. Lubchenco, H. Mooney and M. Troell, 2000. Effect of Aquaculture on World Fish Supplies. Nature, Vol. 405, No. 6790, 2000, pp. 1017-1024. doi:10.1038/35016500.
Piedrahita, R.H., 2003. Reducing the potential environmental impact of tank aquaculture effluents through intensification and recirculation. Aquaculture. 226(1-4), 35-44.
Piedrahita, R.H., Giovannini, P., 1989. Diel aquaculture models: listings, descriptions and operating instructions. Technical Committee Meeting 1989, PD/A CRSP, Davis, CA, 50 pp.
Piedrahita, R.H., W.H. Zachritz II, K. Fitzsimmons and C. Brockway., 1996. Evaluation and improvements of solids removal systems for aquaculture. Pp. 141-150 in G.S. Libey and M.B. Timmons, editors. Aquacultural Engineering Society Proceedings II: Successes and failures in commercial recirculating aquaculture. Northeast Regional Agricultural Engineering Service, Ithaca, New York.
Quazi RM., 2001. Strategic Water Resources Planning: A case Study of Banglandesh. Water Resour. Manage. 15: 165-186.
Read, P., Fernandes, T., 2003. Management of environmental impacts of marine aquaculture in Europe. Aquaculture 226, 139–163.
Remen M., Imsland A.K., Steffanson S.O., Jonassen T.M., Foss A., 2008. Interactive effects of ammonia and oxygen on growth and physiological status of juvenile Atlantic cod (Gadus morhua) – Aquaculture 274: 292-299.
Rosenthal, H., Castell, J. D., Chiba, K., Forster, J. R. M., Hilge, V., Hogendoorn, H.,Mayo, R. D., Muir, J. F., Murray, K. R., Petit, J., Wedemeyer, G. A., Wheaton, F., Wickins, J., 1986. Flow-through and recirculation systems, EIFAC: 100.
Russel Water Gardens, 2011. The HydroBead Vortex. Redmond, WA. [http://www.russellwatergardens.com/Filters/hydrobeadvortex3.php?PHPSESSID=394272e7ca0fa54533fbe7981df4c0a9].
Sammouth S, d’Orbcastel ER, Gasset E, Lemarié G, Breuil G, Marino G, Coeurdacier JL, Fivelstad S and Blancheton JP., 2009. The effect of density on sea bass (Dicentrarchus labrax) performance in a tank-based recirculating system. Aquac Eng 40, 72-78.
Sandu SI, Boardman GD, Watten BJ and Brazil BL., 2002. Factors influencing the nitrification efficiency of fluidized bed filter with a plastic bead medium. Aquac Eng 26, 41-59.
Selective Koi Sales, 2011. Econobead filters. Hainford, UK. [http://www.selectivekoisales .co.uk/shop/index.php?cPath=67_17].
Summerfelt, S.T. 2006. Design and management of conventional fluidized- sand biofilters. Aquac Eng. 34, 275-302.
Summerfelt, S.T., 1996. Engineering design of modular and scaleable recircu-lating systems containing circular tank, microscreen filters, fluidized-sand biofilters, cascade aerators, and low head or u-tube oxygenators. In: Successes and Failures in Commercial Recirculating Aquaculture, Editors Northeast Regional Agricultural Engineering Service (NRAES). NRAES-98, 1, pp. 217–244.
Summerfelt, S.T., Sharrer, M.J., Tsukuda, S.M., Gearheart, M., 2009. Process requirements for achieving full-flow disinfection of recirculating water using ozonation and UV irradiation Aquacult. Eng. 40, 17-27.
Tal, Y., Schreier, H.J., Sowers, K.R., Stubblefield, J.D., Place, A.R., Zohar, Y., 2009. Environmentally sustainable land-based marine aquaculture. Aquaculture 286, 28-35.
Timmons, M.B., Ebeling, J.M., 2007. Recirculating Aquaculture. NRAC Publications, No. 01-007. Cayuga Aqua Ventures, Ithaca, NY, 49.
Verdegem, M. C. J., Bosma, R. H., Verreth, J. A. J., 2006. Reducing water use for animal production through aquaculture. Int. J. Water Resour. Dev. 22, 101-113.
Wedemeyer, G.A., 1996. Physiology of fish in intensive culture systems. Chapman and Hall, New York.
Welch, E.B., Lindell, T., 1992. Ecological Effects of Wastewater. Applied Limnology and Pollutant Effects. Chapman and Hall, London, pp. 76–81.
Wheaton, F. W., Hochheimer, J. N., Kaiser, G. E., Malone, R. F., Krones, M.J., Libey, G. S. Easter, C.C.1994. Nitrification filter design methods. In: Aquaculture Water Reuse Systems: Engineering Design and Management. Development in Aquaculture and Fisheries Science. Vol.27. Timmons MB and Losordo TM, eds. Elsevier, Amsterdam, NL, pp. 127-171.
Wickens, J.F., 1980. Water quality requirements for intensive aquaculture: a review. In: Proceedings of the Symposium on New Developments in the Utilization of Heated Effluents and Recirculation Systems on Intensive Aquaculture, 11th session, pp. 28–30.
Zohar, Y., Tal, Y., Schreier, H. J., Steven, C., Stubblefield, J. and Place., A., 2005. Commercially feasible urban recirculated aquaculture: Addressing the marine sector. In, Urban Aquaculture, B. Costa-Pierce, ed. CABI Publishing, Cambridge, MA, pp. 159-171. | ||||
|
Statistics Article View: 348 PDF Download: 195 |
||||
