GREENHOUSE COOLING USING EARTH-TUBE HEAT EXCHANGER AND EVAPORATIVE COOLING FOR DURING SUMMER SEASON | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 20, Volume 31, Issue 3, July 2014, Page 1065-1094 PDF (1.48 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2014.99123 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| S. M. Abd El- Latif1; S. M. Radwan2; S .A. Hassanain2; I. H. El-Sheikh3; S. S. Kishk4 | ||||
| 1Professor Of Agric. Eng., Agric. Eng. Dept. Fac. Agric., El- Mansoura U., Egypt. | ||||
| 2Professor Of Agric. Eng., Agric. Eng. Dept. Fac. Agric., Suez-Canal U., Egypt. | ||||
| 3Assoc. Professor Of Agric. Eng., Agric. Eng. Dept. Fac. Agric., Suez-Canal U., Egypt. | ||||
| 4Assist. Lect. Of Agric. Eng., Agric. Eng. Dept. Fac. Agric., Suez-Canal U., Egypt. | ||||
| Abstract | ||||
| In this research work an attempt has been made to analysis the thermal performance of the earth-tube heat exchanger (ETHE) during summer season of 2012 (June to September). The experimental work was executed in the experimental farm of Faculty of Agriculture, Suez Canal University, Ismailia Governorate, Egypt (Latitude angle of 30.62ºN, Longitude angle of 32.27ºE, and mean altitude above sea level of 5 m). The ETHE technique was used to utilize the stability of deep soil temperature for reducing the indoor air temperature during the summer season. A computer simulation model has been developed and used based on MATLAB program to determine the depth at which the soil temperature is stabilized. A comparative study between the evaporative cooling system (based on fan-pads system) and the ETHE system was carried out during the summer season to compare weather the two cooling systems differed significantly in the cooling effectiveness to provide and maintain the indoor air temperature within the two greenhouses at the desired level. The obtained data showed that, the depth at which the soil temperature is stabilized was achieved at 3 m deep. The overall thermal efficiency of the ETHE system was 73.85 %. Due to the microclimatic conditions (air temperature and air relative humidity) were at and around the desired level, the growth rate, flowering rate, fruit set rate, and fresh yield of cucumber crop were at high rates and good quality. Data of the computer simulation model of the indoor air and soil temperatures were found to be very closest to that measured. | ||||
| Keywords | ||||
| Greenhouses - Earth-tube heat exchanger; Evaporative cooling - Air and soil temperatures | ||||
| References | ||||
|
Al-Ajmi, F. ; Loveday, D. L. ; and Hanby, V. I. (2006) ''The cooling potential of earth-air heat exchangers for domestic buildings in a desert climate'' Building and Environment, 41, 235-244.
Aldrich, R. A. ; and Bartok, J. W. (1990) ''Greenhouse engineering'' Northeast Regional Agricultural Engineering Service, Comell University, Ithaca, New York, 14853.
Ali, H. M.; Moustafa, S. ; and El-Mansy, H. (1990) ''An efficient greenhouse design for hot climates'' Energy Conversion Management, 30 (4): 433-437.
ANSI/ASAESTANDARDS, American Society of Agricultural Engineers (2003) "Heating, Ventilating and
Cooling Greenhouses" ANSI/ASAE EP 406.4
Argus Control System LTD (2009) "Understanding and using VPD" www.agruscontrols.com, Canada V4B 3Y9.
Arnold, K. A. ; Camplell, G. S. ; Nielsen, D. R. ; Jackson, R. D. ; Chair, A. K. ; and Morthand M. M. (1986) ''Methods of soil analysis'' Part (1) Physical and Mineralogical Methods second edition. American Society of Agronomy, Inc. Ch (15): 383-409.
Ascione, F. ; Bellia, L. ; and Minichiello, F. (2011) ''Earth-to-air heat exchangers for Italian climates'' Renewable Energy 36, 2177-2188.
Bailey, B. J. (1995) "Greenhouse climate control-new challenges" Acta-Horticulturae. 399, 13-23.
Bansal, V. ; Misra, R. ; Agrawal, G. D. ; and Mathur, J. (2010) ''Performance analysis of earth-pipe-air heat exchanger for summer cooling'' Energy and Buildings, 42, 645-648.
Bisoniya, T. S. ; Kumar, A. ; and Baredar, P. (2013) ''Experimental and analytical studies of earth–air heat exchanger (EAHE) systems in India: A review'' Renewable and Sustainable Energy Reviews, 19, 238-246.
Black, C. A. (1965) ''Methods of Soil Analysis'' Society of Testing and Materials, No A, USA.
Chel, A. ; and Tiwari, G. N. (2010) ''Stand-alone photovoltaic (PV) integrated with earth to air heat exchanger (EAHE) for space heating/cooling of adobe house in New Delhi (India)'' Energy Conversion and Management, 51, 393-409.
Duffie, J. A. ; and Beckman, W. A. (1991) ''Solar Engineering of the Thermal Process Wiley'' Interscine New York, USA, 3-44.
Elad, Y. ; Malathrakis, N. E. ; and Dik A. J. (1996) "Biological control of Botrytis-incited diseases and powdery mil-dews in greenhouse crops" Crop Protection. 15(3): 229-238.
El-Sheikh, I. H. (2001) ''Soil heating and climate simulation model for greenhouses'' Ph.D, Thesis Institute for Techniik in Gratenbau and landwirtschaft, Universitat Hanover, Germany.
Garzoli, K. V. (1985) ''A simple greenhouse climate model'' Acta Horticulturae, 174, 393-400.
Ghosal, M. K. ; and Tiwari, G. N. (2006) ''Modeling and parametric studies for thermal performance of an earth-to-air heat exchanger integrated with a greenhouse'' Energy Conversion and Management August, 47 (13-14): 1779-1798.
Ghosal, M. K. ; Tiwari, G. N. ; and Sirivastava, N. S. (2004) ''Thermal modeling of a greenhouse with an integrated earth to air heat exchanger, an experimental validation'' Energy and Buildings, 36(3): 219–227.
Hassan, A. A. (2001) ''Ground Family'' Arabic Text Book, Eldar Elarabia Publishing & Distribution, Cairo, Egypt, PP: 498.
Holman, J. P. (1992) ''Heat transfer'' McGraw-Hill. McGraw-Hill international book company, London, Hamburg, Paris, Sydney, and Tokyo.
Ibrahim, M. A. (1999) ''Predicting microclimatic conditions in greenhouses'' Misr Journal of Agricultural Engineering, 16 (1): 67-82.
Incropera, F. P. ; and Dewitt, D. P. (1996) ''Fundamental of Heat and Mass Transfer'' John wiley &Sons: 886.
Jain, D. ; and Tiwari, G. N. (2002) ''Modeling and optimal design of evaporative cooling system in controlled environment greenhouse'' Energy Conversion and Management, 43, 2235-2250.
Kassem, A. M. (1999) ''Possibilities of using soil heat as a renewable source for conditioned greenhouses'' Ph. D Science, Department of Agricultural Mechanization, Faculty of Agriculture, El- Mansoura University, Egypt.
Kittas, C. ; Bartzanas, T. ; and Jaffarin, A. (2001) ''Greenhouse evaporative cooling: measurement and data analysis'' Transactions of the ASAE, 44 (3): 683-689.
Kittas, C. ; Karamanis, M. ; and Katsoulas, N. (2005) ''Air temperature regime in a forced ventilated greenhouse with rose crop'' Energy and Buildings, 37 (8): 807-812.
Klute, A. (1986): Methods of soil analysis. Physical and Minarological Methods, 2nd Edition, Madison Wisconsin, USA.
Kumar, K. S. ; Tiwari, K. N. ; and Madan, K. (2009) ''Design and technology for greenhouse cooling in tropical and subtropical regions: A review'' Energy and Buildings, 41, 1269-1275.
Kumar, R. ; Ramesh, S. ; and Kaushik, S. C. (2003) ''Performance evaluation and energy conservation potential of earth–air–tunnel system coupled with non- air-conditioned building'' Building and Environment, 38, 807-13.
Lewis, M. J. (1990) ''Physical properties of foods and food processing system'' Ellis Horwood limited.
Li, H. ; Yu. Y. ; Niu, F. ; Shafik, M. ; and Chen, B. (2014) ''Performance of a coupled cooling system with earth-to-air heat exchanger and solar chimney'' Renewable Energy, 62, 468-477.
Mc Adams (1954) ''Heat Transmission'' 3rd edition, Mc Graw – Hill Book Company, New York, USA.
Mujahid, A. M. ; and Alamoud, A. R. (1988) ''An easily designed and constructed photovoltaic pyrheliometer'' Solar &Wind Technology, 5 (2): 127-130.
Nelson, V. P. (1990) ''Greenhouse operation and management'' Third Edition, A Reston Book, Prentice-Hall, Inc, Englewood cliffs, New Jersey, USA, 598pp.
Norton, B. (1992) ''Solar Energy thermal technology'' Springer- Veriag, London, 279.
Pieters, J. G. ; Deltour, J. M. ; and Debruyckere, M. J. (1994) ''Condensation and static heat transfer through greenhouse cover during night'' Trans, ASAE, 37(6) 1965-1972.
Pringer, J. J. ; and Ling, P. P. (2004) "Greenhouse condensation control; Understanding and using vapour pressure deficit" Extension Fact-sheet, Ohio Sate University Extension, USA.
Pringer, J. J. ; and Ling, P. P. (2004) "Greenhouse condensation control; Understanding and using vapour pressure deficit" Extension Fact-sheet, Ohio Sate University Extension, USA.
Sethi, V. P. ; and Sharma, S. K. (2007) ''Survey of cooling technologies for worldwide agricultural greenhouse applications'' Solar Energy, 81, 1447-1459.
Shukla, A. ; Tiwari, G. N. ; and Sodha, M. S. (2008) ''Experimental study of effect of an inner thermal curtain in evaporative cooling system of cascade greenhouse'' Solar Energy, 82 (1): 61-72.
Sonntage, R. ; and Borgnakke, C. (1988) ''Fundamental of Thermodynamics (Sth edit)'' Computer Aided thermodynamic Tables 2 (CATT2) developed by Intellipro,Ggordon van wylen John wiley & Sons, Inc.
Taha, A. (2003) ''Simulation model of energy fluxes in passive solar greenhouse with concrete North wall'' ph.D, Thesis Institute for Techniik in Gratenbau and landwirtschaft, Universitat Hanover, Germany.
Tiwari, G. N. ; Akhtar, M. A. ; Shukla, A. ; and Khan, E. M. (2006) ''Annual thermal performance of greenhouse with an earth–air heat exchanger: An experimental validation'' Renewable Energy, 31, 2432-2446.
Woodson T. ; Coulibaly, Y. ; and Traore E. S. (2012) ''Earth–air heat exchangers for passive air conditioning: case study Burkina Faso'' Journal of Construction in Developing Countries, 17 (1): 21-33 | ||||
|
Statistics Article View: 133 PDF Download: 290 |
||||
