TECHNICAL ANALYSIS OF DIFFERENT POWER RATING OF AGRICULTURAL TRACTORS IN LIBYA | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 1, Volume 31, Issue 2, April 2014, Page 341-358 PDF (1.44 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2014.99541 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| S. M. younis1; G. E. M. Nasr2; M. M. A. Esseid3 | ||||
| 1Prof., Agric. Eng. Dept., Fac. of Agric., Cairo Univ., Giza, Egypt. | ||||
| 2Prof., Agric. Eng. Dept., and Vice Dean for Education and Students affairs Fac. of Agric., Cairo Univ., Giza, Egypt | ||||
| 3M. Sc. Student, Agric. Eng. Dept., Fac. of Agric., Cairo Univ., Giza, Egypt. | ||||
| Abstract | ||||
| The aim of this investigation was to find out the optimum tractor power requirement under Libyan agricultural conditions in order to suggest the most suitable tractor power for the majority of Libyan farmers. A comparison was carried out between two tractor power level, 47HP and 75HP, for the sake of locating the optimum power that could provide the farmer' with his basic needs for a progressive mechanized operations under specific condition. The tested parameters were drawbar pull, slip percentage, fuel consumption, and maneuverability. The lowest wheel slip percentage was recorded with tractor 47HP when operating all implements except with the chisel plough 2st pass. Also it was clear that, there was significance different between the mechanical elements with different types of power that the lowest wheel slip percent was obtained by chisel plough first pass and land leveler. It was clear that the tractor 75HP when currying different equipment, that the fuel consumption (measured in l/h) was higher than the tractor 47 HP. The actual field capacity of tractor 75HP was significantly higher than that of tractor 47HP with different implements.Also it was evident that the field efficiency when tractor 47HP is executing the 1st pass with chisel plough was higher than the efficiency with implemented. Also it was evident that the efficiency when tractor 75hp is executing others the chisel plough 2nd pass is higher than the efficiency with other implements. Also it was evident that the efficiency of tractor 47HP is greater than the efficiency of tractor 75HP in deferent operations. The higher efficiency obtained by 47HP, where the lowest efficiency was recorded with disc plough. The 47HP rating tractor provided the higher value of efficiency in all the tested operations. Consequently it is more suitable for the tested mechanized operations. | ||||
| Keywords | ||||
| Agricultural tractors; mouldboard plough; chisel plough; disc plough and leveler | ||||
| References | ||||
|
Bamigboye, I. and Ojolo, S. (2002). Cost of Operating Farm Tractors. Moor Journal of Agricultural Research, Volume 3 No 2, pp229-232.
Hadas, A. (1997). Soil tilth-the desired soil structural state obtained through proper soil fragmentation and reorientation processes. Soil & Tillage Research, 43:7-40
Hanna, G. B. (1978). Prospects of farm mechanization on small holding in U. A. R. C. F. AMA, spring: 31-34.
Johnson, T.F. and Jose, M.R. (2011). Conservation tillage for cassava (Manihot esculenta crantz) production in the tropics. Soil Till. Res., 113:1-10
Nasr, G. M. (1985) Study of the optimum Tractor Power Requirement under Egyptian Agricultural Conditions, PHD. thesis, Agric. Eng., Fac. of Agric., Cairo Univ.
Sahu, R.K. and Raheman, H. (2008). A decision support system on matching and field performance prediction of tractor-implement system. Computers and electronics in agriculture, 60:76–86
Sandeep Y. and S. Kumar . 2006. Tractor and Implement Ownership and Utilization of Haryana. Agricultural Mechanization in Asia, Africa and Latin America Vol. 37 No.3 pp 15-17.
Serrano, J.M.; Peca, J.O.; Marques da Silva, J.; Pinheiro, A. and Carvalho M. (2007). Tractor energy requirements in disc harrow systems. Biosystems Engineering, 98: 286 – 296
Smith, L.A. (1993). Energy requirements for selected crop production implements. Soil and Tillage Research, 25:281-299
Younis, S. M.(1995). Management of the farm machinery and power, Fac. of Agric., Cairo Univ. | ||||
|
Statistics Article View: 148 PDF Download: 325 |
||||
