UTILIZATION OF A DEVELOPED SOLAR STORAGE AND DRYING SYSTEM FOR CONTINUOUS DEHYDRATION OF SOME LEAFY MEDICINAL PLANTS | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 21, Volume 29, Issue 1, January 2012, Page 377-394 PDF (1.2 MB) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2012.102613 | ||||
 View on SCiNiTO | ||||
| Author | ||||
| Baher M. A. Amer | ||||
| Lec., Agric. Eng.; Fac. of Agric.; Cairo University-Egypt | ||||
| Abstract | ||||
| A developed solar system was used for dehydration some leafy medicinal plants and for storage of solar energy in water. It consisted of a flat-plate collector, a reflector, a drying unit, an auxiliary electric heater and a water tank. The solar system was tested during June to September 2009 for drying Lemon balm (Melissa officinalis L.) and peppermint (Mentha pepperita). Inlet air temperature to the dryer was higher than the ambient temperature and it could be maintained as desired using a temperature controller. Drying was taken about 8 to 10 hours to reduce the moisture contents of Melissa from 70-72 to 9% (wb) and 33 hours to reduce it from 70-72 to 17% (wb) by the hybrid dryer and natural sun drying method, respectively. Moisture content of Peppermint was reduced from 69-71% (wb) to 8-9 % (wb) in 10-12 hours by hybrid dryer and 51 hours by natural sun drying to reduce the moisture contents of it to 10% (wb). The capacity of the dryer was to dry about 16-20 kg of fresh Lemon Balm and also about 16-20 kg of fresh Peppermint per batch for each plant. The color, oil content and appearances of the products dried in the hybrid dryer were better than sun drying method. The dryer was also occupied with an auxiliary heat source to be used whenever adverse weather conditions exist. Using the water tank, about 15-20°C can be maintained in water during the time of sun-shine. During night time,the stored head is transferred from the water to the drying air inside the solar dryer and controls the air temperature through the drying process at night. | ||||
| References | ||||
|
Abdel-Galil, H. S. and Tarhuni, M. M. 2005. Solar drying of medicinal plants under Libyan conditions. Misr J. Agric. Eng., 22 (4): 171-191.
Abdel–Ghaffar, E. 1986. Rock-beds heat surge for solar heated air. Misr J. Agric. Eng., 3 (3): 33- 42.
Amer, B. M. A. 2006. A hybrid solar fruit drying system for small-scale farmers in subtropical and tropical countries. zur Erlangung des akademischen Grades doctor rerum agriculturarum (Dr. rer. agr.), eingereicht an der Landwirtschaftlich-Gärtnerischen Fakultät der Humboldt-Universität zu Berlin.
Amer, B. M. A., Hossain, M. A. and Gottschaslk, K. 2010. Design and performance evaluation of a new hybrid dryer for banana. Energy Conversion and Management, 51(4): 813-820.
Awady, M. N., Mohamed, S. A., EL-Sayed, S. A. and Hassanain A. A. 1993. Utilization of solar energy for drying processes of agricultural products. Misr J. Agric. Eng. 10 (43): 794- 804.
Bala, B. K. 2000. Adaptive research on solar drier for drying mango, pineapple and fish. Final Research Report, Department of Farm Power and Machinery, Bangladesh Agricultural University, Mymensingh.
Bennamoun, L. and Belhamri, A. 2003. Design and simulation of a solar dryer for agricultural products. Journal of Food Engineering. 59: 259-266.
Esper, A. and Mühlbauer, W. 1998. Solar drying-an effective means of food preservation. Renewable Energy. 15: 95-100.
Ghanem, T. H. 1998. Solar energy utilization, specifically on drying or sterilization of animal manure under Egyptian conditions for use as protein supplement in animal feed. Ph. D. Th., Fac. of Agric. EL- Azhar Univ. Vol. 76, 95- 199.
Ghazanfari, A.; Tabil, L. andSokhansanj, S. 2003. Evaluating a solar dryer for in-shell drying of split pistachio nuts. Drying Technology. 21(7): 1357-1368.
Hossain, M. A.; Woods, J. L. and Bala, B. K. 2007.Single-layer drying characteristics and colour kinetics of redchilli. International Journal of Food Science and Technology. 42(11): 1367-1375.
Hossain, M. A. and Bala, B. K. 2007. Drying of hot chilli using solar tunnel dryer. Solar Energy. 81(1):85-92.
Hossain, M. A., Amer, B. M. A. and Gottschalk, K. 2008. Hybrid solar dryer for quality dried tomato. Drying Technology. 26: 1591-1601.
Kassem, A. M., El-batawi, I. E. and Mahassen M. A. Sidky. 2006. Effect of solar energy and other drying methods on quality of some medicinal plants. The 14th Annual Conference of the Misr Society of Agric. Eng.
Maria, T. 1977. Applications of solar energy for heating and cooling of buildings. ASHRAE GRP: 170.
Miller, W. M. 1983. Energy storage via desiccants for food/agricultural applications. Energy in Agriculture. Vol. 2(4), pp. 341-354.
Mühlbauer, W. 1986. Present status of solar crop drying. Energy in Agriculture. 5: 121-127.
Nedkov, N. K. and Georgiev, G. V. 1991. A study of different irrigation practices used for Mentha piperita in Bulgaria. Journal of Essential oil research. 3 (6): 435 – 440.
Paakkonen, K., Havento, J., Galambosi, B. and M. Pyykkonen. 1999. Infared drying of herbs. Agricultural and food Science in Finland. 8 (1): 19 -27.
Sabbah, M. A. 1986. Design and thermal performance of a solar drying system in Riyadh area. J. Coll. Agric. King Saud Univ. Vol. 8(1), pp. 49-75. Riyadh, Saudi Arabia.
Sabbah, M. A., Shokr, A. Z., Soliman, S. N. and Gomaa, A. E. 1999. Thermal performance of different designs of solar air heaters. Misr J. Agric. Eng. 16 (3): 479-501.
Singh, R. K., Lund, D. B. and Buelow, F. H. 1983. Application of Solar Energy in Food processing. II. Food Dehydration. Transactions of the ASAE. 26(5), pp. 1569-1574.
Part of a Book :
Müller, J., and Heindl, A. 2006. Drying of medicinal plants. In Medicinal and aromatic plants-agricultural, commercial, ecological, legal, pharmacological and social aspects, pp 237-252, Berlin, Heidelberg, Germany: Springer-Verlag. | ||||
|
Statistics Article View: 143 PDF Download: 205 |
||||
