Strengthening of Reinforced Concrete Slabs using Carbon Fiber Polymers | ||||
| JES. Journal of Engineering Sciences | ||||
| Article 2, Volume 51, Issue 4, July and August 2023, Page 242-254 PDF (950.3 K) | ||||
| Document Type: Research Paper | ||||
| DOI: 10.21608/jesaun.2023.189658.1202 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
Samiha Aِbd elaziz  1; Eehab A Khalil2; Hamed Hadhoud3
| ||||
| 1Researcher, Construction Research Institute, NWRC, Cairo, Egypt | ||||
| 2Prof. Dr., Construction Research Institute, NWRC, Cairo, Egypt | ||||
| 3professor at cairo univerisity | ||||
| Abstract | ||||
| Several existing reinforced concrete structures (RC) requires improvement in performance for reasons of deterioration. This is due to many factors such as change in code requirements. The current study was assisted by experimental models to investigate the behavior of RC slabs strengthened with carbon fiber reinforced polymer (CFRP) laminates and sheets. Seven RC slabs strengthened with CFRP (laminates and sheets) were tested. The slabs were divided into four groups. The first phase includes one slab without strengthening (reference slab), the second phase includes one slab strengthened with CFRP laminates, and the third phase includes one slab strengthened with CFRP sheets. The fourth phase includes four slabs strengthened with different areas of sheets. The major test parameters included the different types of strengthening materials and the corresponding types of epoxy used for each type of CFRP. A comparison between the two types of CFRP was conducted. The load deflection, load strain and mode of failure were investigated. Test results demonstrated that the flexural strength increased and the ductility reduced with the increase in the area of CFRP sheets. for almost equivalent applied area, CFRP Sheets has more significant influence on the behavior of the strengthened slabs than laminates. Strengthening of RC slabs with CFRP improves the flexural strength capacity for both types. For the same CFRP strength, the sheets showed a cost reduction of 70%. The difference is attributed to the difference in the mechanical properties and the bonding quality of the CFRP material. | ||||
| Keywords | ||||
| Strengthening; Slabs; CFRP; experimental models; laminates | ||||
| References | ||||
|
[1] Rajai Z. Al-Rousan, Mohammad A. Alhassan, Esmail A. AlShuqari. “Shear Nonlinear Behavior of plain concrete beams with DSSF strengthened in flexure with anchored CFRP sheets—Effects of DSSF content on the bonding length of CFRP sheets.” Case Studies in Construction Materials, 9(1), p. e195, (2018).
[2] Omar Al-Ghazawi and Rajai Z. Al-Rousan. “Response of Reinforced Concrete Slabs Strengthened with CFRP.” Journal of Engineering Science and Technology Review 13 (6) (2020) 125 – 129.
[3] Hamdy, K. S., Ahmed, S. E., and Kareem, A. E. “Strengthening of cutouts in existing one-way spanning R. C. flat slabs using CFRP sheets.” International Journal of Concrete Structures and Materials, 11(2) (2017), 327–341.
[4] Ferreiro-Cabello, J.; Fraile-Garcia, E.; Martinez de Pison Ascacibar, E.; Martinez-de-Pison, F.J. Metamodel-based design optimization of structural one-way slabs based on deep learning neural networks to reduce environmental impact. Eng. Struct. 2018, 155, 91–101.
[5] L.Michel, E.Ferriera, A.Agbossoub and P.Hamelina, “Flexural stiffness modelling of RC slab strengthened by externally bonded FRP” Claude Bernard Lyon I university, Composites Part B: Engineering Vol. 40, No.8, December 2009, PP. 758–765.
[6] F.Elgabbas, A.El-Ghandoura, A.Abdelrahmana, and S.El-Diebb, “Different CFRP strengthening techniques for prestressed hollow core concrete slabs: Experimental study and analytical investigation” Ain Shams University, Composite Structures Vol.92, No.2, January 2010, PP. 401–411.
[7] S.J.E. Dias and J.A.O. Barros “NSM shear strengthening technique with CFRP laminates applied in high-strength concrete beams with or without pre cracking” Composites Part B: Engineering, Vol. 43, No.2 , March 2012, PP.290-301.
[8] Scott T. Smith , ShenghuaHu, Seo JinKim and Rudolf Seracino., “FRP strengthened RC slabs anchored with FRP anchors” Engineering Structures, Vol.33, No.4, April 2011, PP.1075-1087.
[9] L.J.Lia, Y.C.Guoa, F.Liua and J.H.Bungeyb., “An experimental and numerical study of the effect of thickness and length of CFRP on performance of repaired reinforced concrete beams” Construction and Building Materials, Vol.20,No.10,December 2006, pp.901–909.
[10] R. Al-Rousan, M.Issa and H.Shabila. “Performance of reinforced concrete slabs strengthened with different types and configurations of CFRP” Department of Civil and Materials Engineering, Composites Part B: Engineering Vol. 43, NO.2, March 2012, PP. 510-521.
[11] Tamer El Maaddawy and Khaled Soudki “Strengthening of reinforced concrete slabs with mechanically-anchored unbonded FRP system” Construction and Research Materials, Vol.22, No.4, April 2008, PP. 444–455.
[12] Ferreiro-Cabello, J.; Fraile-Garcia, E.; Martinez-Camara, E.; Perez-de-la-Parte, M. Sensitivity analysis of life cycle assessment to select reinforced concrete structures with one-way slabs. Eng. Struct. 2017, 132, 586–596.
[13] Ferreiro-Cabello, J.; Fraile-Garcia, E.; Martinez de Pison Ascacibar, E.; Martinez-de-Pison, F.J. Metamodel-based design optimization of structural one-way slabs based on deep learning neural networks to reduce environmental impact. Eng. Struct. 2018, 155, 91–101.
| ||||
|
Statistics Article View: 180 PDF Download: 419 |
||||
