EXPERIMENTAL INVESTIGATION ON SOME PARAMETERS OF RICE STRAW ASH - FLY ASH GEOPOLYMER MORTAR | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 16, Volume 35, Issue 3, July 2018, Page 1083-1098 PDF (576.19 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2018.95603 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| M. I. Morsy1; H. H. Mohamed2 | ||||
| 1Lecturer, Agric. & Biosystems Eng. Dept., Fac. of Agric. El-Shatby, Alexandria University, Egypt. | ||||
| 2Lecturer, Soil & Ag. Eng. Dept., Fac of Agric. Saba Basha, Alexandria University, Egypt. | ||||
| Abstract | ||||
| Concrete is one of the main materials in the construction industry. The Ordinary Portland Cement (OPC) concrete is vastly used as the main binder in construction industry which leads to depletion of natural resources in order to manufacture large quantities of OPC. Environmental hazards result from OPC production have become a major concern today. Nevertheless, Geopolymer concrete production (GC) is a new environment friendly construction material, due to less emission of carbon dioxide. An experimental study on some engineering properties of Geopolymer Mortar (GM) prepared using the fly ash (FA) and rice straw ash (RSA) is presented in this research. FA was replaced with RSA by 0, 5, 10, 15, 20, and 25% where the sodium silicate and sodium hydroxide were used as alkaline activator. The casted GM was divided in two main groups to study the effect of curing temperature. The first group was cured at room temperature for 28 days. The second group was cured at 80ºC for 24 hours in an oven curing tank then in room temperature for 27 days. The test results show that compression strength and flexural strength of geopolymer mortar increase when the percentage of RSA increases up to 5% replacement. The geopolymer materials exhibited strength increases after temperature exposure for 28 day. | ||||
| Keywords | ||||
| Geopolymer Mortar; fly ash; Rice Straw Ash; Compressive and flexural strength | ||||
| References | ||||
|
ASTM C618. Standard specification for coal fly ash and raw or calcined natural pozzolan for use as a mineral admixture in concrete. Annual Book of ASTM Standards. Philadelphia, USA; 1993.
ASTM C618 – 08. Standard Specification for Coal Fly Ash and Raw or Calcined Natural Pozzolan for Use in Concrete. ASTM International. Retrieved 2008-09-18.
Davidovits, J., 1994. High-Alkali Cements for 21st Century Concretes. Concrete Technology, Past, Present and Future. 144, pp.383-397.
Fernandez-Jimenez, A. and A. Palomo, 2003. Characterisation of fly ashes Potential reactivity as alkaline cements. Fuel.;82: 2259–2265.
Foaud, A. A. and F. Abdelradi, 2016. Analysis of the Rice Straw Recycling Value Added in Egypt Agricultural Economics. J. Agric. Econom. and Social Sci., Mansoura Univ., Vol. (11): 1039 – 1045.
Gonen, T. and S. Yazicioglu, (2007). The influence of mineral admixtures on the short and long-term performance of concrete. Building and Environment, 42: 3080-3085.
IPCC, 2007. International Panel on Climate Change. Climate Change. The Physical Science Basis. Cambridge University Press, Cambridge.
Kalapathy, U., A. Proctor and J. Shultz, 2002. An improved method for production of silica from rice hull ash, Bioresour.Techn. 285-289.
Li, Z.; Z. Ding, and Y. Zhang, 2004. Development of sustainable cementations materials. International workshop on sustainable development and concrete technology, Beijing, China, pp. 55-76.
Piyaphanuwat, R. and S. Asavapisit, 2009. Effect of Black Rice Husk Ash Substituted OPC on Strength and Leaching of Solidified Plating Sludge, Journal of Metals, Materials and Minerals, Vol.19 No. 2, pp. 85-89.
Worrell, E.; L. Price, and L. Ozawa, 2001. Carbon Dioxide Emission from the Global Cement Industry . Annu. Rev. Energy Environ. 26:303–29.
Yuan, Q., J. Pump, and R. Conrad, 2014. Straw application in paddy soil enhances methane production also from other carbon sources. Biogeoscience 11, 237–246. | ||||
|
Statistics Article View: 233 PDF Download: 243 |
||||
