EFFECT OF DIFFERENT DRYING METHODS ON MINT LEAVES PHYSICAL AND QUALITY PROPERTIES | ||||
| Misr Journal of Agricultural Engineering | ||||
| Article 13, Volume 32, Issue 3, July 2015, Page 1161-1184 PDF (900.96 K) | ||||
| Document Type: Original Article | ||||
| DOI: 10.21608/mjae.2015.98270 | ||||
 View on SCiNiTO | ||||
| Authors | ||||
| A. T. Taha; M. H. Keshek; M. Baggash | ||||
| Ag. Eng. Dept., Fac. of Ag., Menoufia Univ., Egypt. | ||||
| Abstract | ||||
| Three drying methods were used for drying mint leaves, oven drying (40, 50, 60 and 70 oC), microwave drying (180, 360, 540, 720 and 900 Watt) and direct solar drying with three levels of load (0.5, 1.25 and 5kg/m2).The drying characteristics and the quality aspects of the dried mint leaves were studied. From initial moisture content (7.65 g.w/g.d.m.) to achieve the equilibrium moisture content the drying time was 5 minutes by microwave drier at use powers 900 and 720 Watt with loading level 0.5 kg/m2, while the highest time took for drying mint was 20 hours to achieve equilibrium moisture content when use oven drier at 40 oC. Meanwhile, the solar drier required 8 hr. to achieve the final moisture content of mint leaves (0.11 g. w./g. d .m) at both 1.25 and 0.5 kg/m2 loading levels. The results showed that drying of the mint leaves at temperature 50 oC with loading rate 1.25 kg/m2 was the best treatment from all treatments were studied in this work to getting the highest amount of essential oil. Midili - kucuk, model adequately described the oven and solar drying behaviors and logarithmic model adequately described the microwave drying behaviors. | ||||
| Keywords | ||||
| mint leaves; microwave; oven drying; solar drying | ||||
| References | ||||
|
Akgul A. (1993) Spice science and technology. Turkish Association of Food Technologists. Publ. no 15. Ankara Turkey.
Akpinar EK. ( 2010) Drying of mint leaves in a solar drier and under open sun: Modeling, performance analyses. Energy Conversion and Management 51 2407–2418
Board, N, (2003) The complete technology book of essential oils (aromatic chemicals). S. 1: asia pacific Business press inc.
Bondaruk, J., Markowski, M., Blaszczak, W., (2007).Effect of drying conditions on the
Doymaz I.( 2006) Thin-layer drying behavior of mint leaves. J Food Eng, 74:370– 5.
Drouzas, A.E., Tsami, E., Saravacos, G.D., 1999. Microwave/vacuum drying of model fruit gels. Journal of Food Engineering 39, 117–122.
during thermal degradation of chlorophyll in mint and coriander puree. Journal of Food Engineering 86, 379–387.
Ekechukwu, O. V (1999) "Review of solar-energy drying systems I: an overview of drying principles and theory". Energy Convers Manage; 40:593–613.
El-Awady, M. N., Mohamed, S. A., El-Sayed, A. S. and Hassanain, A. A. (1993). Utilization of solar energy for drying processes of agricultural products. Misr, J. Ag. Eng., 10(4):794-804.
Elminir, H. K., Ghitas, A. E., El-Hussainy, F., Hamid, R., Beheary, M. M. and Abdel-Moneim, K. M. (2006). Optimum solar flat-plate collector slope: Case study for Helwan, Egypt. Energy Conversion and Management, 47: 624–637
El-Yateem, S. M. E. (1995) "Studies on the drying of some vegetables and fruits". M.Sc Thesis, Food Technology, Dep., Faculty of Agriculture, El-MinufiyaUniversity.
Ertekin, C. and Yaldiz, O. (2004). Drying of eggplant and selection of a suitable hin layer-drying model. Journal of Food Engineering;(53): 349–359
Fathima A, Begum K, Rajalakshmi D. (2001) Microwave drying of selected greens and their sensory characteristics. Plant Foods Human Nutr;56:303–11.
Ghanem, T. H. (2003). Improving Thermal Efficiency of A Flat Plate Solar Collector Using Nontraditional Coating Under Quasisteady conditions. Misr J. Ag. Eng., 20 (2): 498-514.
Gunhan T, Demir V, Hancioglu E, Hepbasli A(2005).Mathematical modelling of drying of bay leaves. Energy Convers Manage;46(11–12):1667–79.
Hamrouni-Sellami, I., Wannes, W.A., Bettaieb, I., Berrima, S., Chahed, T., Marzouk, B., Limam, F., (2011). Qualitative and quantitative changes in the essential oil of Laurus nobilis L. leaves as affected by different drying methods. Food Chem. 126, 691–769.
Idlimam, A.; Ethmane Kane, C. S. and Kouhila, M. (2007). Single layer drying behavior of grenade peel in a forced convective solar drier .Revue des Energies Renouvelables , 10 (2): 191 – 203.
Keshek, M. H. A. (2007).Drying Characteristics of Some Vegetables and Fruits by Different Solar Drying Systems .M .Sc Thesis, Department of Agricultural Engineering, Faculty of Agriculture, Minofiya University, Egypt.
Maharaj, V., Sankat, C.K., (1996). Quality changes in dehydrated dasheen leaves effect of blanching pre-treatments and drying conditions. Food Research International 29, 563–568. Engineering, 48, 177–182.
Maskan A, Kaya S, Maskan M. (2002) Hot air and sun drying of grape leather (pestil). J Food Eng;54:81–8.
Maskan, M. (2001). Drying, shrinkage and rehydration characteristics of kiwifruits during hot air and microwave drying. Journal of Food Engineering, 48, 177–182.
nutritional and sensory quality of leafy vegetables. Plant Foods for Human Nutrition 37, 291–298.
Omidbaigi R, Sefidkon F, Kazemi F (2004). Influence of drying methods on the essential oil content and composition of Roman chamomile. Flavour Fragr. J., 19: 196-198.
Onayemi, O., Okeibuno Badifu, G.I., (1987). Effect of blanching and drying methods on
Ozbek B, Dadali G. (2007). Thin-layer drying characteristics and modelling of mint leaves undergoing microwave treatment. J Food Eng;83(4):541–9.
quality of vacuum-microwave dried potato cubes. Journal of Food Engineering81, 164–175.
Radünz LL (2004). Dried rosemary pepper, and mint together on guaco different temperatures and its influence on the quantity and quality of active ingredients. PhD dissertation, University of Viçosa, Viçosa, Brazil.
Rahimmalek, M., Goli, S.A.H., (2013). Evaluation of six drying treatments with respect to essential oil yield, composition and color characteristics of Thymus daenensis subsp. daenensis. Celak leaves. Ind Crops Prod. 42, 613–619.
Rudra, S.G., Singh, H., Basu, S., Shivhare, U.S., (2008). Enthalpy entropy compensation
Soysal, A., Oztekin, S., Eren, O., (2006). Microwave drying of parsley: modeling, kinetics, and energy aspects. Biosyst. Eng. 93 (4), 403– 413.
Therdthai N, Zhou W. (2009) Characterization of microwave vacuum drying and hot air drying of mint leaves (Mentha cordifolia Opiz ex Fresen). J Food Eng;91:482–9.
Venskutonis PR (1997).Effect of drying on the volatile constituents of thyme (Thymus vulgaris L.) and sage (Salvia officinalis L.). Food Chem., 59: 219-227 | ||||
|
Statistics Article View: 182 PDF Download: 263 |
||||
